Electrolux EILFU17GS, Technical & Service Manual

Page: 29 / 96

C Co on nd de en ns se err R Re ep plla ac ce em me en ntt
1. Disconnect electrical supply to refrigerator.
2. Remove compressor access panel.
3. Recover refrigerant by using EPA approved
recovery system.
4. Remove condenser fan mounting screws.
5. Unplug fan motor harness located in back of
fan motor.
6. Remove fan motor and fan blade.
7. After refrigerant is completely recovered,
disconnect inlet and discharge lines from
condenser.
8. Lift front of condenser and pull out of retainers
mounted to the drain pan.
9. Remove old condenser out the back of
cabinet.
10. Install replacement condenser.
11. Remove original filter-drier.
12. Install new filter-drier at condenser outlet.
13. Evacuate and charge the system using
recommended procedure described under
Evacuating and Recharging.
14. Reassemble unit.
4-7
R Re effrriig ge erra attiio on n S Sy ys stte em m
10. Reform both suction and discharge lines to
align with new compressor. If they are too
short, use additional lengths of tubing. Joints
should overlap 0.5” to provide sufficient area
for good solder joint. Clean and mark area
where tubing should be cut. Cut tubing with
tubing cutter. Work as quickly as possible to
avoid letting moisture and air into system.
11. Solder all connections according to soldering
procedure.
12. Remove original filter-drier.
13. Install new filter-drier at condenser outlet.
14. Evacuate and charge system using recom-
mended procedure described under
Evacuating and Recharging.
15. Reconnect compressor terminal leads in
accordance with refrigerator wiring diagram.
16. Reassemble unit.
CAUTION
D DO O N NO OT T u un nb brra az ze e o olld d ffiilltte err--d drriie err ffrro om m s sy ys stte em m..
T Th hiis s w wiillll v va ap po orriiz ze e a an nd d d drriiv ve e m mo oiis sttu urre e ffrro om m
d de es siic cc ca an ntt b ba ac ck k iin ntto o s sy ys stte em m.. T Th he e o olld d ffiilltte err--d drriie err
s sh ho ou ulld d b be e c cu utt o ou utt o off s sy ys stte em m..
CAUTION
D DO O N NO OT T u un nb brra az ze e o olld d ffiilltte err--d drriie err ffrro om m s sy ys stte em m..
T Th hiis s w wiillll v va ap po orriiz ze e a an nd d d drriiv ve e m mo oiis sttu urre e ffrro om m
d de es siic cc ca an ntt b ba ac ck k iin ntto o s sy ys stte em m.. T Th he e o olld d ffiilltte err--d drriie err
s sh ho ou ulld d b be e c cu utt o ou utt o off s sy ys stte em m..
NOTE
T Th he e ffo ollllo ow wiin ng g iin ns sttrru uc cttiio on ns s a arre e g ge en ne erra alliiz ze ed d tto o
h he ellp p tth he e tte ec ch hn niic ciia an n u un nd de errs stta an nd d tth he e p prro oc ce ed du urre es s
o off s se ea alle ed d s sy ys stte em m rre ep pa aiirrs s.. S Se ee e S Se ec cttiio on n 5 5
C Co om mp po on ne en ntt T Te ea arrd do ow wn n o on n tth he e e ex xa ac ctt s stte ep ps s o off
a ac cc ce es ss siin ng g tth he e c co om mp po on ne en ntts s o off tth he e rre effrriig ge erra attiio on n
s sy ys stte em m..