Daedong KIOTI EX35, Manual

Page: 195 / 238

7
-
2
7
-
22
maintenance ex35(c)/ex40(c)/ex45(c)/ex50(c)
7
7
-
2
7
-
22
maintenance ex35(c)/ex40(c)/ex45(c)/ex50(c)
(1) adjusting Bolt
(a) adjusting Belt tension (B) pull
AdJUSTINg fAN BElT TEN -
SION (v)
in order to extend the fan belt’s life-
time, the tension of the belt should
be correctly adjusted if it slips. the
belt tension should be inspected reg-
ularly according to the following pro-
cedure:
1. stop the engine and apply the
parking brake.
2. open the hood and remove the
left side cover.
3. remove the mounting bolts and
adjusting bolt of the alternator.
H11O632A
3. if the fuel pipes and hose clamps
are found damaged or deterio-
rated earlier than two years, then
change them immediately.
4. after the fuel pipe and hose
clamps have been changed, bleed
the fuel system.
(1) fuel pipe (2) tightening Band
ChECKINg fUEl lINES (U)
although checking the fuel pipe con-
nection is recommended every 100
service hours, it should be done ev-
ery 6 months if operation does not
exceed 100 hours in 6 months.
1. if the hose clamps are loose, ap-
ply a slight coat of lubricant onto
the threads and securely tighten it.
2. the fuel pipe is made of rubber
and ages regardless of period of
service. change the fuel pipe to-
gether with the hose clamps every
two years and securely tighten.
H11O631A

when changing fuel pipes, be
careful not to allow dust or dirt
to enter the fuel system. Con -
taminations in the fuel system
could damage the fuel sys -
tem or injuction pump.Pay ex -
tra caution to the fuel pump to
prevent dust from entering it.
IMPORTANT

Stop the engine when check -
ing the items above.

The fuel pipes are subject to
wear and aging. failure to per -
form periodic inspections may
lead to a fuel leak. fuel leaking
on a hot engine could cause a
fire.
WaRninG
M47-EU-07.indd 23 2012-03-14 오후 7:19:17