Cushman Hauler 4x4 Crew Diesel 2019, Operator'S Manual

Page: 5 / 72

! WARNING Indicates a hazardous situation which, if not
avoided, could result in death or serious injury. 3
Division I — Safety
This vehicle is not a toy and can be hazardous
to operate.
• Always go slowly and be extra careful when operating on unfamiliar terrain. Always be
alert to changing terrain conditions when operating this vehicle.
• Never operate on excessively rough, slippery, or loose terrain.
• Always follow proper procedures for turning as described in this manual. Practice turn-
ing at slow speeds before attempting to turn at faster speeds. Do not turn at excessive
speed.
• Always have the vehicle checked by an authorized Cushman dealer if it has been
involved in an accident.
• Never operate on hills too steep for your abilities. Practice on smaller hills before
attempting larger hills.
• Always follow proper procedures for climbing hills as described in this manual. Check
the terrain carefully before you start up any hill. Never climb hills with slippery or loose
surfaces. Never depress the accelerator suddenly or make gear changes while moving.
Never go over the top of any hill at high speed.
• Always follow proper procedures for going down hills and for braking on hills as
described in this manual. Check the terrain carefully before you start down any hill.
Never go down a hill at high speed. Avoid going down a hill at an angle which would
cause the vehicle to lean sharply to one side. Go straight down the hill where possible.
• Always be careful when you decide to climb or descend a hill and never turn on a hill.
Drive straight up or down inclines and not across them. If you must cross the side of a
hill, drive slowly and stop or turn downhill if you feel the vehicle may tip over.
• Always use proper procedures if you stall or roll backward when climbing a hill. To
avoid stalling, maintain a steady speed when climbing a hill. If you stall or roll back-
wards, follow the special procedure for braking described in this manual.
• Always check for obstacles before operating in a new area. Never attempt to operate
over large obstacles, such as large rocks or fallen trees. Always follow proper proce-
dures when operating over obstacles as described in this manual.
• Always be careful of skidding or sliding. On slippery surfaces, such as ice, go slowly
and be very cautious in order to reduce the chance of skidding or sliding out of control.
• Never operate this vehicle in fast-flowing water or in water deeper than the floorboard.
Remember that wet brakes may have reduced stopping capability. Test your brakes after
leaving water. If necessary, apply them lightly several times to let friction dry out the
pads.
• Always be sure there are no obstacles or people behind you when you operate in
reverse. When it is safe to proceed in reverse, go slowly. Avoid turning at sharp angles
in reverse.
• Always use the size and type tires specified in this manual. Always maintain proper tire
pressure as described in this manual.
• Never improperly install or improperly use accessories on this vehicle.
• Never exceed the stated load capacity for this vehicle. Cargo should be properly distrib-
uted and securely attached. Reduce speed and follow instructions in this manual for car-
rying cargo or pulling a trailer and allow greater distance for braking.
• Operation of this vehicle is restricted to people 16 years of age and older who possess a
valid driver’s license. Passengers must be able to place both feet flat on the floor while
keeping their back against the back of the seat and holding on to an available handhold.