BA_Migros_ED3EX_GB 09.02.2011 12:13 Uhr Seite 46
Probedruck
C
M
Y
CM
MY
CY CMY
K
1. Controller
1.1 The display does not light up after being switched on.
Cause:
Repair:
Battery incorrectly positioned
>insert the battery again
Battery defect
>contact dealer
Cable/contact error
>contact dealer
Electronics defect
>contact dealer
1.2 The display unit switches off during the ride.
Cause:
Repair:
Battery empty
>completely recharge battery again
Electronics defect
>contact dealer
Plug connection has loosened
>contact dealer
2. Battery
2.1 No LED lights up after battery status display has been pressed.
Cause:
Repair:
Battery empty
>completely recharge battery again
Cells in battery pack defective
>contact dealer
2.2 The operating distance of the battery has been drastically reduced.
Cause:
Repair:
The battery is exhausted (aged)
>exchange battery
The charger is defective
>contact dealer
Charging plug/charging cable damaged
>contact dealer
3. Motor
3.1 No performance from the motor but the controller and the battery still function.
Cause:
Repair:
The motor cable under the cover
is disconnected
>control plug
other cable/contact error
>contact dealer
Pedal sensor defective
>contact dealer
Electronic defective
>contact dealer
4. Charging unit
See Page 17 Charging and Care of the Battery.
Malfunctions/Causes/Repair
ED-3EX Pedelec Technical Data
Pedelec/EPAC
6
(Electrical Power Assist Cycle)
icycle auxiliary actuator with 250W motor, up to
25 km/h, activated through pedal sensor.
BLDC gear motor BLDC stands for Brushless-DC,
i.e., a brushless, electronically commutated 3-
phase direct current motor with a maximum
continuous rated power of 250W.
BLDC motor controller with digital programme
control in accordance with the European standard.
Three different driving modes: ECO, NORMAL &
SPORT. In addition, three geographic profiles P1-
P3. The auxiliary actuator is automatically activated
when the pedals are used, providing assistance up
to 25 km/h. The auxiliary actuator is automatically
cut off when the brakes are applied.
37V 8.8A h (320 Wh) lithium ion battery made in
Europe with 5 LED capacity display, weight 2.4 kg,
up to 500 charge cycles or 3 – 4 years life expectancy
by optimum usage.
CC-CV charging unit with 2A charging current
full charge of the 9Ah battery lasts approximately
8.8 h.
Highly dependent on the selected operating mode,
personal mode of operation and other factors.
See Page 134
“ Operating range and its Factors”
Drive System
Motor
Controller
Battery
Charging Unit
Operating
Distance
6
EPAC = Pedelec
142
Operating instructions
ED-3 EX
