C24AB
16
DAILY:
1. Charge Batteries as needed. Batteries should generally be charged daily. Unplug the
charger from both the Solo XT550 and the 115 volt outlet each morning. Do not leave
the charger plugged into the Solo XT550 when it is not operating because there is
always a small current drain for the charger interlock relay.
MONTHLY:
1. Check tire pressure and tread wear. Maintain 45 lbs. in front tires and 45 lbs. in the
rear tires.
2. Check and tighten all nuts and bolts.
3. Parking Brake: Be sure the brake will hold you when parked on an incline. If it will not,
it must be replaced. Consult your ConvaQuip dealer.
4. Inspect all electrical connections for damage and corrosion.
ANNUALLY:
It is recommended that your ConvaQuip dealer perform an annual inspection of your
Solo XT550. Many times he or she may be able to prevent problems before they
happen, saving time and inconvenience.
GENERAL INFORMATION:
Cleaning: The body covers on your Solo XT550 are made from a high grade ABS
plastic. Use only a mild soap and water for cleaning. Do not use any petroleum based
solvents since they can damage the finish. Clean the vinyl seat cushion with a mild
soap and water. The optional cloth seat cushion should be vacuumed or brushed as
needed and cleaned by a furniture cleaning service when necessary.
ROUTINE MAINTENANCE
SECTION 12
WARNING
Air pressure inside the tire can cause an explosion if the bolts holding the wheel
halves together are removed before releasing all pressure from inside the tire. THIS
COULD RESULT IN SEVERE BODILY INJURY OR PROPERTY DAMAGE. Do not
attempt to disassemble a wheel until all the air has been released from the tire.
CAUTION
The Solo XT550 is an electrical device. Do not spray with water from a source such
as a garden hose or a pressure washer. Take extreme care not to expose the
electrical connections and components to any moisture. Cleaning should be done
with a damp cloth. Operating the Solo XT550 or energizing its electrical components
while wet can damage the components and create hazardous operating conditions.
Avoid leaving the Solo XT550 out, uncovered, in the rain. IF the controller does
become wet, DO NOT operate the Solo XT550 for at least 24 hours or until it has had
time for the unit to dry thoroughly.
