Coleman 2302-A, Instruction Manual

Page: 3 / 41

2
Contents
General Safety Information 2-3
System Overview
3-4
To Set Up 4-6
Use and Operation 6-7
Helpful Hints 8
Storage 8
Maintenance 8
Chart of Indicators 9
Troubleshooting Guide 10
Technical Characteristics 10
Replacement Parts 10
Circuit Diagram 11
Warranty 12
General Safety Information
This manual contains important information about the assembly, operation
and maintenance of this water heater. General safety information is
presented in these first few pages and is also located throughout the
manual. Particular attention should be paid to information accompanied by
the safety alert symbol “ DANGER”, “ WARNING”, “ CAUTION”.
Keep this manual for future reference and to educate new users of this
product. This manual should be read in conjunction with the labeling on the
product.
Safety precautions are essential when any mechanical or propane fueled
equipment is involved. These precautions are necessary when using,
storing, and servicing. Using this equipment with the respect and caution
demanded will reduce the possibilities of personal injury or property
damage.
The symbols shown below are used throughout this manual. Always heed
these precautions, as they are essential when using any mechanical or
propane fueled equipment.
DANGER
DANGER indicates an imminently hazardous situation which, if not
avoided, will result in death or serious injury.
WARNING
WARNING indicates a potentially hazardous situation which, if not
avoided, could result in death or serious injury.
CAUTION
CAUTION indicates a potentially hazardous situation which, if not
avoided, may result in minor or moderate personal injury, or property
damage.
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. If odor continues, keep away from the
appliance and immediately all your fire
department.
Failure to follow these instructions could result
in fire or explosion which could cause property
damage, personal injury or death.
WARNING
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
General Safety Information (continued)
DANGER
CARBON MONOXIDE
HAZARD
This appliance can produce
carbon monoxide which has
no odor.
Using it in an enclosed space
can kill you.
Never use this appliance in
an enclosed space such as a
camper, tent, car or home.
DANGER
Water temperature over
125°F (52°C) can cause
server burns instantly or
death from scalds.
Children, disabled and
elderly are at highest risk of
being scalded.
See instruction manual
before setting temperature
at water heater.
Feel water before bathing
or showering.
BURN
HOT
DANGER
EXPLOSION - FIRE HAZARD
• Never store propane near high heat, open flames, pilot lights, direct
sunlight, other ignition sources or where temperatures exceed 120
degrees F (49°C).
• Propane is heavier than air and can accumulate in low places. If you
smell gas, leave the area immediately.
• Never install or remove propane tank while heater is operating, near
flame, pilot lights, other ignition sources or while heater is hot to
touch.
• During operation, this product can be a source of ignition. Never
ignite or use the heater in spaces that contain or may contain volatile
or air-borne combustibles, or products such as gasoline, solvents,
paint thinner, dust particles or unknown chemicals. Minimum
clearances from combustible materials: 12 inches (30.5 cm) from
sides & 48 inches (122 cm) from the top.
• Provide adequate clearances around air openings into the product.
Do not obstruct the flow of combustion and ventilation air.
WARNING
Not for home or recreational vehicle use.
We cannot foresee every use which may be made of our products.
Check with your local fire safety authority if you have questions
about use.
Other standards govern the use of fuel gases and heat producing
products for specific uses. Your local authorities can advise you about
these.
• Never refill disposable cylinders.
• Use the preset regulator that is installed in the water heater. Do not
attempt to adjust.