Thermal Solutions AMP 1000, Инструкция по установке, эксплуатации и обслуживанию

Страница: 79 / 88

79
APPENDIX B: Figures
I. Hazard Definitions 4
II. Read Before Proceeding 5
III. Product Rating, Specifications, and Dimensional Data 7
Figure 1: AMP Boiler Dimensions 9
IV. AMP Component Identification 10
Figure 2: Component Identification 12
Figure 3: Component Identification 13
V. Unpacking The AMP 14
Figure 4: Lifting Lugs 14
VI. Pre-Installation and Mounting 15
VII. Venting 18
Figure 5: Direct Vent Terminal Clearances 25
Figure 6: Other than Direct Vent Terminal Clearances 25
Figure 8: Horizontal Sidewall Termination 29
Figure 7: Slopped Roof Termination 29
Figure 9: Vertical Roof Termination 29
Figure 10: Snorkel Termination 30
Figure 11: Flexible Vent in Masonry Chimney with Separate Combustion Air Intake 32
Figure 12: Multiple Appliance Direct Vent Termination 34
VIII. Condensate Disposal 37
Figure 13: Condensate Trap Assembly 37
IX. Hydronic Piping 39
Figure 14: Factory Supplied Water Manifold 39
Figure 15: Heat exchanger water pressure loss 40
X. Heating Boiler Piping diagrams 45
Figure 16: Single Boiler, Primary/Secondary Piping 45
Figure 17: Multiple Boiler, Primary/Secondary with Common Header Piping 46
Figure 18: Multiple Boiler, Primary Reverse-Return Piping 47
Figure 19: Single Boiler, Variable Primary Piping 47
Figure 20: Multiple Boiler, Primary Secondary Piping with Hydronic Separator 48
Figure 21: Single Boiler with Indirect Domestic Hot Water Heating 48
XI. Hot Water Supply Boiler Water Piping 49
Figure 22: Hot Water Outlet Manifold (AMPW) 49
Figure 23: Single Appliance, Single Tank 54
Figure 24: Two Temperatures, Single Appliance, Single Tank 55
Figure 25: Single Appliance, Two Tanks 56
Figure 26: Two Appliances, Single Tank 57
Figure 27: Two Appliances, Two Tanks 58
XII. Gas Piping 59
Figure 28: The AMP Gas Train 59
Figure 29: High/Low Gas Pressure Switch 61
XIII. Electrical 62
Figure 30: Single Phase Wire Diagram 64
Figure 31: Three Phase Wire Diagram 65
XIV. System Start-up 68
Figure 32: Operating Instructions 69
Figure 33: Gas Valve Air/Fuel Adjustment 70
XV. Service and Maintenance 73
Figure 34: Igniter Electrode Assembly 75
Figure 35: Igniter Electrode Gap 75
Figure 36: UV Scanner Assembly 76
Figure 37: Burner Door Opening 76