Sole Diesel SM-82, Руководство оператора

Страница: 38 / 56

TROUBLESHOOTING
38
Operator’s Manual Marine Diesel Engines
Revision 0. 05/2016
ENGINE FAILURE PROBABLE CAUSES RECOMMENDED ACTIONS SECTION
FAILURE TO START
PANEL SVT
Key switch
Check the pin connections and check that they
have voltage.
-
Electronic board
Check that goes voltage electronic board to
micro relay.
-
ELECTRICAL SYSTEM
ENGINE
Blown fuse
Replace the controller fuse. If the fuse blows
again, troubleshoot the controller.
6.8
Battery discharged or dead Recharge or replace the battery. 6.8
Battery connections loose, corroded or incorrect
Verify that the battery connections are correct,
clean and tight.
6.8
Faulty cranking relay/stop solenoid
Check the cranking relay and the stop solenoid. If
necessary, replace.
-
Faulty starter motor Replace if it is inoperative. 6.8
GENERAL Compression weak Check the compression. 6.3
LUBRICATION SYSTEM Oil viscosity too high
Check the oil viscosity (according to technical
specifications).
6.4
FUEL SYSTEM
Fuel pump faulty or clogged Check fuel pump inlet. 6.5
Fuel lines obstructed Check fuel lines. 6.5
Fuel filter clogged Replace fuel filter. 6.5
Faulty injection pump Contact with our dealer -
Air in fuel system Bleed fuel system. 6.5
Fuel injectors dirty or faulty
Clean, test and/or replace the inoperative fuel
injector.
6.5
Fuel injection timing out of adjustment Adjust the fuel injection timing. 6.5
Fuel tank empty or fuel valve shut off
Add fuel and move the fuel valve to opened
position.
6.5
INLET AND EXHAUST
SYSTEM
Air filter clogged Replace air filter element. 6.7