OPERATION
19
Operator’s Manual Marine Diesel Engines
Revision 0. 05/2016
Section 5 - Operation
5.1. Prestart Checklist
Follow these checks and inspections to ensure the correct engine operation. In addition,
some checks require verification after unit starts.
AIR CLEANER:
Check for a clean and installed air cleaner element to prevent unfiltered
air from entering the engine.
AIR INLETS
: Check for clean and unobstructed air inlets.
BATTERY:
Check for tight battery connections
.
COOLANT LEVEL:
Check the coolant level according to coolant circuit capacity
.
DRIVE BELTS:
Check the belt condition and tension of the coolant pump and battery
charging alternator belt
.
EXHAUST SYSTEM:
Check for exhaust leaks and blockages. Check the silencer and piping
condition and check for tight exhaust system connections
.
Check that the exhaust outlet is unobstructed.
FUEL LEVEL:
Check the fuel level and keep the tank(s) full to ensure adequate fuel supply.
OIL LEVEL:
Maintain the oil level below dipstick high mark and above dipstick low mark
.
OPERATING AREA:
Check for obstructions that could block the flow of admission air.
SEAWATER PUMP PRIMING:
Prime the seawater pump before initial startup. To prime the
pump:
-
Close the seacock
-
Remove the hose from the seawater-filter outlet
-
Fill the hose and seawater pump with clean water
-
Reconnect the hose to the water filter outlet
-
Open the seacock
Confirm seawater pump operation on startup as indicated by water discharge from the
exhaust outlet.
5.2. Cranking the Engine
1.
TURN ON THE KEY POSITION.
To start all instruments
with fuel pump.
2.
TURN THE KEY TO PREHEATING POSITION.
To heat
the engine for a few seconds before the start.
3.
TURN THE KEY TO STARTER POSITION.
To feed the
starter and start the engine.
If the engine doesn't start after several attempts to start, may cause water entering in the
engine. See warning label on the engine.
After starting up the engine, check the following points. If you find anything wrong,
immediately stop the engine, and then investigate the cause.
Содержание SM-82
