Pereko AGRO Multi 12, Руководство по эксплуатации и обслуживанию

Страница: 16 / 116

16
Page Operation and maintenance manual for the AGRO Multi series boilers with feeders. The producer reserves the right to introduce technical modifications.
then remove soot from fl ue gas ducts, 4. remove deposited dust,
ash and fuel residues from external casing of the boiler.
Pay attention to tidiness in the boiler room. Any other ob-
jects, except these necessary for the operation of the boiler
should not be stored there.
Take care of the good condition of the boiler and
hydraulic system:
• Check, and tighten screws fi xing the motoreducer and fuel
container, from time to time.
• Periodically check the tightness of the water system and
tightness of doors of the boiler, fl ue and chimney. Replace
a gasket in boiler and doors if necessary.
• Periodical inspections should be performed once per year
during standstill of the boiler.
• To execute inspection of the boiler and establish a scope of
possible repairs the boiler should be precisely cleaned from
the residues after combustion from the
fi re side.
• Major repairs of the boiler resulting from the incorrect op-
eration, occurred failures or mechanical damages shall be
carried out immediately when they are detected by the
producer’s service.
4.8. Boiler operation in emergency mode
4.8.1. Emergency stop of boiler
operation
Boiler should be stopped always in case of: 1. water leak from
the boiler, 2. temperature increase over 90°C or 3. necessity to
re
fi ll evaporated water in the system and heaters.
To stop operation of the boiler you should carry out oper-
ations listed in point Stop of boiler operation . If it is necessary
to stop the boiler more quickly you should take out heat from
igniter using a metal shovel to a metal container, remove heat to
the outside and extinguish it with water there.
NOTE! Do not extinguish glowing fuel with water in the
boiler room!