PB Heat Peerless Boilers GM Series, Инструкция по установке, эксплуатации и обслуживанию

Страница: 2 / 43

USING THIS MANUAL 1
A. INSTALLATION SEQUENCE . . . . . . . . . . . . . 1
B. SPECIAL ATTENTION BOXES . . . . . . . . . . . . 1
1. PREINSTALLATION 2
A. ACCESSIBILITY CLEARANCES . . . . . . . . . . . 2
B. CLEARANCE FROM COMBUSTIBLE
CONSTRUCTION . . . . . . . . . . . . . . . . . . . . . . 2
C. COMBUSTION & VENTILATION AIR . . . . . . . 2
D. INSTALLATION SURVEY . . . . . . . . . . . . . . . . 5
E. CIRCULATORS . . . . . . . . . . . . . . . . . . . . . . . . 6
F. PLANNING THE LAYOUT . . . . . . . . . . . . . . . 6
G. BOILER WATER TREATMENT . . . . . . . . . . . . 6
2. BOILER SET-UP 7
3. WATER PIPING & CONTROLS 8
A. BOILER SUPPLY & RETURN . . . . . . . . . . . . . 8
B. SAFETY RELIEF VALVE . . . . . . . . . . . . . . . . . 9
C. LOW WATER CUT-OFF . . . . . . . . . . . . . . . . . 9
D. PIPING FOR ZONED SYSTEMS . . . . . . . . . . 10
E. EXPANSION TANK . . . . . . . . . . . . . . . . . . . 11
F. INDIRECT-FIRED WATER HEATER . . . . . . . 11
G. FREEZE PROTECTION . . . . . . . . . . . . . . . . . 11
4. VENTING 12
A. DRAFT HOOD . . . . . . . . . . . . . . . . . . . . . . . . 12
B. BLOCKED VENT SWITCH . . . . . . . . . . . . . . 12
C. AUTOMATIC VENT DAMPER
INSTALLATION – GENERAL . . . . . . . . . . . . 13
D. VENT REDUCER –
GM-e-05 & GM-e-06 ONLY . . . . . . . . . . . . . 13
E. VENT PIPING & CHIMNEY . . . . . . . . . . . . . . 13
F. BOILER REMOVAL FROM COMMON
VENTING SYSTEM . . . . . . . . . . . . . . . . . . . . 14
5. GAS PIPING 16
6. ELECTRICAL 18
A. WIRING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
B. SEQUENCE OF OPERATION,
INTERMITTENT IGNITION . . . . . . . . . . . . . . 20
7. CSD CODE REQUIREMENTS 21
A. GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
B. CSD PART CF REQUIREMENTS . . . . . . . . . 21
C. CSD PART CW REQUIREMENTS . . . . . . . . 21
D. MODULAR OR MULTIPLE BOILERS . . . . . . 21
E. CSD PART CE ELECTRICAL
REQUIREMENTS . . . . . . . . . . . . . . . . . . . . . 21
8. START-UP PROCEDURES 22
A. COMPLETING THE INSTALLATION . . . . . . 22
B. CONTROL DESCRIPTIONS . . . . . . . . . . . . . 25
C. ADJUSTMENT OF GAS PRESSURE
REGULATOR . . . . . . . . . . . . . . . . . . . . . . . . 25
D. CHECKING BURNER INPUT . . . . . . . . . . . . . 25
E. CHECK-OUT PROCEDURE . . . . . . . . . . . . . . 26
9. TROUBLESHOOTING 27
A. SHUT-DOWN CAUSED BY PILOT OUTAGE,
VENT SAFETY SHUTOFF SWITCH OR
FLAME ROLLOUT SAFETY SHUTOFF
SWITCH . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
B. TROUBLESHOOTING GUIDES . . . . . . . . . . 27
10. MAINTENANCE 30
A. GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
B. DAILY (WITH BOILER IN USE) . . . . . . . . . . 31
C. WEEKLY (WITH BOILER IN USE) . . . . . . . . 31
D. MONTHLY (WITH BOILER IN USE) . . . . . . . 31
E. ANNUALLY (BEFORE START OF HEATING
SEASON) . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
11. BOILER DIMENSIONS & RATINGS 33
12. REPAIR PARTS 34
TABLE OF CONTENTS
TABLE OF CONTENTS