Napoleon HMF100, Инструкция по установке и эксплуатации

Страница: 2 / 44

W415-1066 / A / 03.06.12
2
TABLE OF CONTENTS
NOTE: Changes, other than editorial, are denoted by a vertical line in the margin.
1.0 INsTALLATION OvERvIEw 3
2.0 INTRODUCTION 4
2.1 dimenSionS 5
2.2 generAl inSTrucTionS 5
2.3 generAl informATion 7
2.3.1 feATureS 7
2.3.2 heATing SPecificATionS 7
2.3.3 elecTricAl SPecificATionS 7
2.3.4 oPTionAl moduleS 7
2.3.5 APPlicAble STAndArdS 7
2.3.6 cAliforniA ProP65 7
2.4 rATing PlATe informATion 7
3.0 INsTALLATION pLANNINg 8
3.1 locATion And cleArAnceS 8
3.2 ouTSide combuSTion Air 8
4.0 INsTALLATION 11
4.1 crATed uniT conTAinS 11
4.2 recommended STeP 11
4.3 removAl of furnAce from bASe of Skid 12
4.4 locATing reTurn Air filTer 13
4.5 elecTricAl locATionS And connecTionS 14
4.5.1 SuPPly lineS 14
4.5.2 limiT hArneSS 17
4.5.3 mounTing And Wiring The fAn/limiT SWiTch 18
4.5.4 Securing Wire hArneSSeS 20
4.6 SecondAry Air TubeS/bAffleS inSTAllATion 21
4.7 brick overvieW 21
4.8 door hAndle inSTAllATion 21
4.9 oPTionAl elecTric bAck uP furnAce 22
5.0 CLEARANCE TO COMBUsTIBLE MATERIALs/ pLENUM AND vENTINg INsTALLATION 26
5.1 flue / chimney for hmf100 in configurATionS 26
5.1.1 conTrolling drAfT 26
5.1.2 meASuring drAfT 26
5.2 minimum cleArAnce To combuSTibleS 27
5.3 generAl Plenum And ducTing - cleArAnce To combuSTibleS 27
5.3.1 minimum ceiling heighT requiremenTS 27
5.3.2 inSTAllATion WiTh reTurn/SuPPly PlenumS And comPleTe ducT SySTem 27
5.3.3 inSTAllATion WiTh The hmfk-dP diffuSion Plenum 28
5.4 ember SToP 29
6.0 gENERAL OpERATINg INsTRUCTIONs 30
6.1 drAfT conTrol 30
6.3 PoWer ouT oPerATion 31
6.2 conTrol SySTem - SecondAry furnAce "Wood/elecTric" configurATion 31
6.4 conTrol SySTem - Summer fAn 32
6.5 oPerATing SoundS And SmellS 32
6.6 STArTing A fire 32
6.7 fuel loAding And burn cycle 34
6.8 re-loAding The APPliAnce 34
6.9 flASh fireS 35
6.10 ASh removAl ProcedureS 35
6.11 inSPecTion of flueS And chimneyS 36
7.0 MAINTENANCE 37
7.1 run-AWAy or chimney fire 37
7.2 creoSoTe formATion And removAl 37
7.2.1 chimney mAinTenAnce 37
7.3 fire eXTinguiSherS And Smoke deTecTorS 38
7.5 SelecTing Wood 38
7.4 glASS And gASkeT rePlAcemenT 38
7.6 firebrickS And bAffleS 38
7.7 glASS rePlAcemenT 39
7.9 filTerS 39
7.8 cAre of glASS (if equiPPed) 39
8.0 REpLACEMENTs 40
9.0 TROUBLE sHOOTINg gUIDE 41
10.0 wARRANTY 42
11.0 sERvICE HIsTORY 43
12.0 NOTEs 44