Malibu Boats Response, Руководство пользователя

Страница: 89 / 112

Engine/Drive Train
Engine
For information on engine service, maintenance and break-in period, please refer to your
engine owner’s manual. The Required Maintenance Schedule included in this manual covers
the minimum maintenance required for Indmar engine packages. The Maintenance
Worksheet included in this manual outlines safety checks, lubrication and general service
that should be performed at regular intervals. It is recommended that any engine replacement
parts used for maintenance or repair be supplied by an authorized Malibu dealer.
Engine Specifications
Notes
1) Minimum recorded compression in any one cylinder should not be less than 70% of the highest recorded cylinder.
2) Measured using an accurate shop tachometer at normal operating temperature. Idle RPM on EFI models is not adjustable.
3) Timing must be set using special procedures indicated in the appropriate service manual. Timing cannot be set using
conventional methods. Special tool(s) required.
4) Always use dipstick to determine exact quantity of oil required. Do not fill above “FULL” mark.
5) Do not over fill. Correct level is at the “Full Cold” mark on the coolant recovery bottle when coolant is cold.
I P M L 1 . 8 6 Y L / 3 S L / 2 S L 7 S L ) 3 8 3 ( L 2 . 6 I P M L 7 . 5 d e t e r u b r a C L 7 . 5 s l e d o M e n i g n E
Number of Cylinders
) L 1 . 8 ( D I C 6 9 4 ) L 0 . 6 ( D I C 4 6 3 ) L 0 . 7 ( D I C 7 2 4 ) L 3 . 6 ( D I C 3 8 3 t n e m e c a l p s i D
Bore/Stroke
4.0012 x 3.8 in.
( 101.63 x 96.52 mm)
4.125 x 4.00 in.
(104.8 x 101.6 mm)
3.898 x 3.622 in.
(99 x 92 mm)
4.25 x 4.37 in.
(108 x 111 mm)
1 : 1 . 9 1 : 1 . 0 1 1 : 0 . 1 1 1 : 7 . 9 o i t a R n o i s s e r p m o C
Compression Pressure (Note 1)
Idle RPM in Neutral (Note 2)
Operating Range at WOT
4400-4800 RPM 5000-5400 RPM
Oil Pressure at Idle 5 PSI (34 kPa) Minimum
Oil Pressure at 2000 RPM 10 PSI (69 kPa) Minimum
Fuel Pump Pressure 8 PSI Maximum (55.2 kPa)
Electrical System
Minimum Battery Requirements
Firing Order
Spark Plug Type
AC 41-983
) m m 6 7 . ( . n i 0 3 0 . p a G g u l P k r a p S
Base Timing at 1000 RPM (Note 3)
10° BTDC
Thermostat
Crankcase (With Filter) (Note 4) 10 Quarts (9.5L)
Closed Cooling Systen (Note 5) 14-16 Quarts (13.2-15.1L)
In-Line 1:1 Transmission (Note 4) 4.2 Quarts (4L) 15W40
In-Line Reduction Gear (Note 4) 4.2 Quarts (4L) 15W40
ZF Ski Vee Transmission (Note 4)
ZF V-Drive Transmission (Note 4)
Walter V-Drive
2008 Malibu Engines
Fluid Capacities
V-8
350 CID (5.7L)
9.4:1
4.0012 x 3.480 in.
(101.63 x 88.39 mm)
Minimum 100 PSI (690 kPa)
650 ± 50 RPM
M P R 0 0 6 5 - 0 0 2 5 M P R 0 0 2 5 - 0 0 6 4
4 PSI (41 kPa) Minimum Hot
18 PSI (124 kPa) Minimum Hot
Pennzoil PZ3, AC-PF25
650 cca/700 mca/120Ah
AC-PF454 (on engine)
Pennzoil PZ3 (remote)
Oil Filter
12 Volt DC Negative (-) Ground
60 PSI Minimum at Keyup (414 kPa)
3 - 4 - 5 - 6 - 2 - 7 - 8 - 1 2 - 7 - 5 - 6 - 3 - 4 - 8 - 1
5 8 9 - 1 4 C A 3 9 9 - 1 4 r o 2 3 9 - 1 4 C A
) m m 3 . 1 ( . n i 0 4 0 . ) m m 5 . 1 ( . n i 0 6 0 .
Nonadjustable
160°F (71°C)
4.2 Quarts (4 L) Pennzoil 15W40
0.5 Quart (0.5 L) Pennzoil SAE 30 Motor Oil
5.5 Quarts (5.25 L) with Filter
12-14 Quarts (11.4-13.3 L)
1.7 Quarts (1.6 L) Dexron 3 ATF
2.12 Quarts (2 L) Pennzoil 15W40
2.12 qt (2 L) Main Gearbox, 1.0 qt (1.06 L) V-drive - Dexron 3
4-5
Chapter 4_08.qxd: Chapter 4 doc.qxd 11/12/07 3:39 PM Page 5