Landoll Brillion SS4, Руководство оператора

Страница: 20 / 56

2-6 7K555-2401
ASSEMBLY
TABLE OF CONTENTS
Acre Meter Installation -
Optional
The Acre Meter Kit consists of three main parts, the Acre
Meter, the Pick-Up Switch, and the Magnet Wheel
Assembly. The Acre Meter is mounted on the front left
side of the Seed Box.
WARNING
NOTE
Alignment of the Pick-Up Switch and Magnet Wheel
Assembly is critical. Improper alignment will cause the
Acre Meter to record acres erratically or not at all.
1. Mount the Acre Meter Assembly to the front left side
of the Seed Box below the bend. See Figure 2-10.
Place the Acre Meter Assembly Bracket against the
Seed Box as a guide for the two 13/32" diameter
holes. Drill holes into the Seed Box.
2. Attach the Acre Meter Assembly Bracket to the Seed
Box with 3/8-16 x 1 Bolts, Flat Washers, Lock
Washers, and Nuts.
Figure 2-10: Mounting Acre Meter
3. On the Seeder back left side, install the Pick-Up
Switch Bracket with the Transmission Shaft Bearing
Bolts, Lock Washers and Nuts.
See Figure 2-11.
4. Press the Magnet Wheel Assembly onto the
Transmission Shaft. Secure to Shaft with Set Screw.
5. Attach the Pick-Up Switch to the Pick-Up Switch
Bracket with #8-32 X 1-1/4 Screws, Flat Washers and
Flange Locknut. Do not tighten at this time.
6. Attach the Pick-Up Switch short ground wire to the
small hole in the Pick-Up Switch Bracket with #6-32 x
1/2 Screw and Nut. Remove paint under the wire
connector to assure a good electrical ground
connection.
Figure 2-11: Pick-Up Switch Bracket
7. Adjust the Pick-Up Switch on the Pick-Up Switch
Bracket so the centerline of Magnet Wheel Assembly
and Pick-Up Switch are horizontally and vertically
aligned with maximum 1/8" between the Magnet
Wheel Assembly and the Pick-Up Switch. Tighten
#8-32 Screws.
See Figure 2-12.
Figure 2-12: Pick-Up Switch Adjustment
Do not pressure clean with air or water.
Acre Meter
Assembly
Nut,3/8-16 Lock Washer,3/8
Flat Washer,3/8
Bolt,3/8-16 x 1
Nut,
5/16-18
Tie Wrap
Bolt,
5/16-18 x 1
Flange
Nut,#8-32
Nut,#6-32
Lock
Washer,5/16
Set
Screw
Magnet
Wheel Asm
Pick-Up
Switch Bracket
Flat
Washer,#8
Screw,#8-32
x 1-1/4
Pick-Up Switch
Screw,#6-32 x 1/2
1/8" Max
Pick-Up Switch
Bracket
Magnet Wheel
Assembly
Pick-Up Switch