V.A.C.
ATS Operations and Maintenance Manual
21
12.0
REAR CHASSIS PLATE REPLACEMENT
12.1
Remove the Front Housing.
12.2
Disconnect the Battery.
12.3
Remove the Canister Housing.
12.4
Remove the Front Plate with Display and Board
12.5
Remove the Charger and the Valve.
12.6
Remove the battery
12.7
Undo the six screws holding the plate to the Rear Housing, and
withdraw the Chassis.
12.8
Remove the Pump.
12.9
Reverse the above procedure to reassemble the unit.
13.0
REAR HOUSING REPLACEMENT
13.1
Remove the Front Housing.
13.2
Disconnect the Battery.
13.3
Remove the Canister Housing.
13.4
Remove the 6 screws holding the complete chassis to the Rear
Housing, and move the complete chassis to the right to access the IEC
Inlet.
13.5
Disconnect the Charger Board from the IEC inlet.
13.6
Disconnect the LED lead from the Charger Board, and remove the
Chassis from the rear housing.
13.7
Remove the Switch Protector and LED from the Rear Housing as
described in section 20.
13.8
Remove the IEC switch as described in section 19.
13.9
Re-assemble the unit in the new Rear Housing by reversing the above
procedure.
14.0
IV POLE CLAMP REPLACEMENT
14.1
Remove the Front Housing.
14.2
Disconnect the Battery.
14.3
Remove the Canister Housing.
14.4
Using a small screwdriver, press the IV
Pole Clamp retaining pin to release the
Clamp from the Rear Housing as shown.
14.5
Pull the Clamp down and away.
14.6
Insert the new Clamp into the recess on
the exterior of the Rear Housing.
14.7
Push up and ensure that the clamp locks
into position.
14.8
Re-assemble the unit by reversing the
above procedure.
NOTE:
Ensure that the IV Pole Clamp is correctly
secured and functions before re-assembling the
14.4
14.5 & 14.6
RESTRICTED USE
Certain pages of this manual are designated
“Restricted Use Only.” Information contained on
those designated pages may be used solely to
facilitate the proper maintenance and repair of
KCI products identified herein. If these terms are
unacceptable, immediately remove those
designated pages and return them to KCI, Attn:
Legal Dept. Refer to qualified service personnel
who are authorized by KCI for proper
maintenance and repair
