1
1. GENERAL RULES
To make the truck and you safety, operator should obey these rules below:
1.
Only trained and authorized operator shall be permitted to operate the truck.
2.
Before start truck you should check all control and alarm device, if there are
any damaged or objection, you could not operate it until repaired it.
3.
When carry the load, the weight should not much overload. The fork shall
insert in the load entirely and well proportioned. It is not permitted use only
one fork to load.
4.
You should operate the truck smoothly when start, turning, travel, brake and
parking. On a slick or wet road, you should decrease speed when turning.
5.
Load travel should lower the goods down and tilt the mast backwards.
6.
Be carefully when traveled on a grade. If the slope angle is bigger than 10
%
,
travel forward up slope and backward down slope. Never turn sideways and
stack load on an incline.
7.
Notice the foot passenger, barrier, pothole and the clearance upside.
8.
It is prohibit picking up a man or standing on the fork.
9.
No permitted to stand or walk under the fork.
10.
No permitted to operate the truck or attachment on other position except the
operator’s seats.
11.
Do not carry the load unpackaged. Be carefully to carry these goods with large
size.
12.
Notice the load not drop from the load bracket for those trucks that overall
maximum lift height is higher than 3 meters. If necessary, make some
protective measure.
13.
Travel with load as low as possible and tilt back the mast.
14.
Before driving over a dock-board or bridge-plate, be sure that it is properly
secured and strong enough to sustain the weight.
15.
Make sure that there is no naked flame near the area, never smoke. The driver
should not remain seated when adding fuel.
16.
The truck with attachments should be treated as a loaded truck.
17.
When leave the truck, you should let the fork down, make the shift lever neutral
shut down the engine and cut the power. Parking on a grade, make sure to
tighten the brake lever. If necessary, use a block when parking on a grade for a
long time.
18.
If the truck suddenly get out of order, or for leakage of electrolyte
，
hydraulic oil
or brake oil, when lifting goods or grade climbing, it needs to rush to repair and
let the truck be in safe state, then connect with maintainer or sales
representative.
19.
In the process of install and assemble, it will be noise and libration. Please
