2019-03-19
411-198M
YP4025A-48TR20
Operating Instructions
68
Long-Term Storage
Complete Parking steps first.
1. Park the implement name indoors if possible, per the
steps above. Great Plains recommends
parking/storing in the raised configuration, folded, on
the parking stands and with all lift cylinder locks
installed.
2. If no hopper or seed box is mounted, cap air box.
3. If empty seed box or hopper is mounted, close the
seed gates and the lids.
4. If partially-loaded seed box is mounted, close seed
gate, and remove seed box. If partially loaded
hopper is present, unload seed via clean-out doors
on air box. Store product only without seed.
5. Open airbox clean-out door. Clean out residual seed.
6. Close airbox clean-out doors. Using product fan,
blow seed to meters, cleaning out the lines.
7. Remove seed disks from meters (this is primarily to
relieve pressure on brushes). Clean disks of residue
build-up (see Caution at right). Use mild soap,
non-abrasive scrubbers, and hot or warm water. If
using sealed storage, dry disks prior to storage.
8. Close seed inlet shutters at meters (to prevent pest
entry to seed hoses). Thoroughly clean seed and
seed treatment residue from seed meters. See
” on page 108, for more
information.
9. Close all clean-out doors and ports. Shut off all
Y-tubes.
10. Apply grease to exposed cylinder rods to prevent
rust.
11. Flush fertilizer lines (if present). Flush system with
RV anti-freeze if there is any chance of freezing prior
to next implement use.
12. Empty and clean fertilizer strainers.
13. Lubricate all points listed in Maintenance to prevent
rust.
14. Clean product of mud, dirt, excess oil and grease.
15. Inspect YP4025A-48TR20 for worn or damaged
parts. Make repairs and service during off season.
16. Use spray paint to cover scratches, chips, and worn
areas on the product to protect the metal.
17. Cover YP4025A-48TR20 with a tarp if stored
outside.
Storage: Fertilizer Option
The pump, strainer and manifold system require special
attention prior to storage. See “
Figure 66
Product Ready for Parking
29290
Possible Chemical Hazard:
Seed disks will have talc and graphite residue, and may have
residues of hazardous seed treatments. Do not wash disks
where food is prepared, or where cookware or dinnerware is
washed. Wear gloves when washing disks. Avoid spray.
Although the disks are dishwasher-safe, do not wash them in
an appliance also used for food cookware or dinnerware.
Removing the seed boxes/hoppers increases the life of the air
box seals, which are otherwise apt to be permanently
compressed if stored under load off-season.
Do not store optional bulk hopper outside on the ground.
Raise it on blocks, securing it in place to prevent from falling
over or blowing around by wind. Store inside if possible.
