Cruisers Yachts 520 Express Series, Руководство пользователя

Страница: 132 / 140

10-2
520 Express Series
520 Express Series
TROUBLESHOOTING
The following charts will assist you in finding
and correcting minor mechanical and
electrical problems with your yacht. Contact
your nearest authorized Cruisers Yachts
Dealer for problems and procedures
requiring the skill of a trained service
technician.
To correct a problem, first determine what
the problem is. Then eliminate the simpler
causes, working to the more complex
causes.
Engine and Power Train
NOTE
For further troubleshooting
information other than given here,
refer to the engine owner’s manual in
the Skipper’s Kit.

WARNING
Disconnect battery cables before
making checks or adjustments
around engine and electrical
components. Personal injury or
damage to the yacht may occur.

WARNING
DO NOT get close enough to make
contact with any running machinery
moving parts, such as the engine,
generator or propeller. Contact may
result in loss of body parts,
strangulation, burns, and/or severe
loss of blood resulting in serious
injury or death. Keep all machinery
guards in place when machinery is
operating.
PROBLEM POSSIBLE CAUSE SOLUTION
Engine will not start Fuel valves are closed or fuel tank is
empty.
Contaminated fuel.
Loose wiring or bad key switch.
DC main and/or ignition circuit
breakers are OFF.
Check fuel valves or fill tank.
Check fuel for contaminants or water. If fuel is contaminated, drain
tank and lines, flush with clean fuel and replace fuel filters.
See Cruisers Yachts Dealer for service.
Look for any loose connections. See Cruisers Yachts Dealer to
replace switch if necessary.
Turn all breakers ON.
Low or no starter speed Weak or bad battery. Have battery tested or charged.
Starter will not crank or turn engine
crankshaft Shift levers not in NEUTRAL.
Corroded battery terminals.
Loose wiring connections.
Weak or discharged battery.
Defective starting switch.
Make sure shift levers are in NEUTRAL.
Clean terminals.
Clean and tighten all wire connections.
Charge battery.
See Cruisers Yachts Dealer for switch replacement.
Downloaded
from
Cruisers
Owners
Forum
http://www.CruisersOwnersForum.com