BlueLine HAZINATOR, Руководство по эксплуатации и обслуживанию

Страница: 24 / 48

SECTION 4
NOTE: Additional engine service information can
be obtained from the provided Kohler Operation
and Maintenance manual. If service or repair is
required, contact an authorized Kohler Service
Center. They will require the serial number of the
engine.
VACUUM PUMP
NOTE: Refer to the provided Vacuum Pump
Operation and Service Manual for specific
instructions.
Lubrication: BLUELINE recommends that you
use only AEON PD Synthetic Blower Lubricant in
the gear end of the vacuum pump for all operating
temperatures. AEON PD is formulated specifically
for positive displacement blower service to provide
maximum blower protection at any temperature.
One filling of AEON PD will last a minimum of
twice as long as a premium mineral oil.
NOTE: AEON PD (Part # 13-004) is the only oil
that BLUELINE puts in the vacuum pump at the
factory. Adding petroleum oil to synthetic oil is
NOT recommended.
1. Check the oil level weekly to ensure the proper
level. Too little oil will damage and ruin the
bearings and gears. Too much oil will result in
overheating.
2. A lubrication cup has been provided at the front
of the console, to prevent rust from building up
inside of the vacuum pump.
Run the unit for at least 2 minutes to remove any
moisture from the vacuum pump. Then, spray WD-
40 (or Equivalent) into the lubrication cup for
5
seconds while the unit is running and the vacuum
inlet ports are sealed. This procedure should be
done at the end of
every working day .
3. Drain, flush and replace the oil every 1000
hours or yearly, whichever comes first.
The bearings on the pulley end of the vacuum
pump require grease lubrication every
100 hours .
Grease the bearings until grease comes out of the
vent holes on the vacuum pump. Use extreme
pressure bearing grease of the spec: NLGI Grade 2
EP (Part # 13-002).
WATER PUMP
Refer to the provided Water Pump Operation
Manual for specific instructions.
1. Check the crankcase oil level daily to ensure the
proper level. If the level has dropped, check for the
source of leakage and repair.
2. After 50 hours operation, change the crankcase
oil with CAT Pump Crankcase Oil,
BLUELINE HAZINATOR
®
19