BlueLine HAZINATOR, Руководство по эксплуатации и обслуживанию

Страница: 25 / 48

SECTION 4
(Part # 13-000). Change the crankcase oil every
500 hours thereafter.
VACUUM INLET FILTER
1. The vacuum inlet filter in the waste recovery
tank should be inspected
daily , and removed and
cleaned weekly. The filter will last for a long
period of time if this is done.
2. Inspect the vacuum filter inside the waste
recovery tank. Remove and clean filter if there is
any lint or debris present.
!
When removing the vacuum inlet filter, grip the
plastic hexagon section of the filter. Grasping
filter by the screen will damage or destroy the
filter.
DRIVE BELTS, PULLEYS & HUBS
1. Check pulley set screws and hub screws after the
first
50 hours of operation and again at 100 hours.
Re-torque these screws with a torque wrench.
Follow the torque values on the following table.
Check pulley set screws and hub screws every
500
hours thereafter.
!
Ensure that when you re-torque the screws, you
use a clockwise pattern and continue until the
proper torque is achieved.
TORQUE VALUES
Component Inch/lbs Foot/lbs
Engine Hub 720 60
Vacuum Pump Hub 192 16
2. If wear or glazing is discovered, replacement is
recommended.
WATER POND
®
1. The float valve should be checked at least
monthly for proper operation. If overfilling is
noted, check the plunger for proper seating.
STAINLESS STEEL
ACCUMULATOR
Sealed 250 pound nitrogen accumulator. Change
every 2000 hours or as needed.
PRESSURE REGULATOR
Lubricate the o-rings in the pressure regulator
every
100 hours.
Use only o-ring lubricant (Part # 13-003).
VACUUM HOSES
To ensure maximum hose life, BLUELINE
recommends that you wash out the hoses with
fresh water
daily.
BATTERY
!
Explosive gases, Dangerous acid!
Batteries contain sulfuric acid. To prevent acid
burns, avoid contact with skin, eyes and
clothing. Batteries also produce explosive
hydrogen gases while charging. To prevent fire
or explosion, charge batteries only in a well
ventilated area. Keep sparks, open flames, as
well as any other sources of ignition away from
batteries at all times. Remove all jewelry prior
to servicing batteries. Keep batteries out of the
reach of children.
Before disconnecting the negative (-) ground
cable, ensure that all switches are in the OFF
position. If ON, a spark could occur at the
BLUELINE HAZINATOR
®
20