Atwood hydro flame 7900-II series, Информационное руководство, Страница: 3 / 16

3
Listed below are several safety related items that you the (owner)
should follow each heating season to assure continued safe operation
of the furnace. A periodic inspection of the furnace by a qualified
service agent is also recommended.
•
Inspect furnace venting. Venting must be free of obstructions,
void of soot and properly terminated to the atmosphere. Make
sure that the vent assembly is positioned tight against out door
screens on 8500 and 8900 series.
•
Periodically inspect the vent for obstructions or presence of soot.
Soot is formed whenever combustion is incomplete. This is your
visual warning that the furnace is operating in an unsafe manner.
If soot is present, immediately shut furnace down and contact
your dealer or a qualified service person.
•
Keep furnace clean. More frequent cleaning may be required due
to excessive lint from carpeting, bedding material, pet hair etc. It
is imperative that control compartments, burners and circulating
air passageways of the appliance be kept clean and
unobstructed.
•
The motor is permanently lubricated and requires no oiling.
•
Keep the furnace area clear of any combustible materials,
gasoline, or other flammable vapor and liquids.
•
Before operating furnace, check the location of the furnace vent to
make sure it will not be blocked by the opening of any door on the
trailer. If it can be blocked, do not operate the furnace with the
door open.
•
Do not restrict the flow of combustion air or the warm air
circulation to the furnace. To do so could cause personal injury
and/or death.
•
Never operate the furnace if you smell gas. Do not assume that
the smell of gas in your RV is normal. Any time you detect the
odor of gas, it is to be considered life threatening and corrected
immediately. Extinguish any open flames including cigarettes and
evacuate all persons from the vehicle. Shut off gas supply at LP
gas bottle. (See safety notice in this manual).
•
Immediately shut furnace down and call a service agency if
furnace cycles erratically or delays on ignition.
•
Never attempt to repair the furnace yourself. Seek the help of a
qualified service person.
•
Never restrict the ducting installed by your trailer manufacturer.
To do so could cause improper furnace operation.
•
Do not install air boosters in the duct system. Such devices will
cause the furnace to cycle on limit and to have erratic sail switch
operation.
•
Clothing or other flammable material should not be placed on or
near the appliance.
•
Always follow the Operating Instructions. Do not deviate from the
step-by-step procedures.
•
When considering add-on rooms, porch or patio, attention must
be given to the venting of our furnace. For your safety, do not
terminate furnace vent inside add-on rooms, screen porch or onto
patios. Doing so will result in products of combustion being vented
into the room or occupied areas.
•
In any installation in which the vent of the appliance can be
covered due to the construction of the RV or some special feature
of the RV such as slide out, pop-up etc. Always insure that the
appliance cannot be operated by setting the thermostat to the
positive “OFF” position and shutting off all electrical and gas
supply to the appliance. Never operate furnace with vent covered.
MAINTENANCE AND CLEANING
SERVICING
CAUTION
PERSONAL INJURY
All sheet metal edges are sharp care should be taken when
handling or brushing up against them to avoid cuts.
WARNING
FIRE OR EXPLOSION
•
Improper installation, adjustment, alteration, service or
maintenance can cause property damage, personal
injury or loss of life. Refer to the installation instructions
and/or owners manual provided with this appliance.
•
Installations, repairs and preventive maintenance
should be done by a qualified Service Technician only.
WARNING
FIRE OR EXPLOSION
•
DO NOT refuel gasoline tanks or LP tanks unless the
gas has been turned OFF at the LP tank disabling all
gas appliances and pilot lights.
•
DO NOT over fill LP gas tanks.
•
LP tanks must be filled by a qualified gas supplier only.
Follow tank manufacture’s operating instructions located
on tank.
•
Liquid gas from an over filled tank can be forced
through the pressure regulator resulting in high pressure
gas escaping, causing fire/explosions.
WARNING
POSSIBLE INJURY OR DEATH
Do not use this appliance if any part has been under water. A
flood-damaged furnace is extremely dangerous. Attempts to use
the furnace can result in fire or explosion.
A qualified service agency should be contacted to inspect the
furnace and to replace all gas controls, control system parts,
electrical parts that have been wet or the furnace if deemed
necessary.
WARNING
POSSIBLE INJURY OR DEATH
“
Should the gas supply fail to shut off or if overheating occurs, shut
off the gas valve to the furnace before shutting off the electrical
supply.”
WARNING
POSSIBLE INJURY OR DEATH
Do not install screens over the vent for any reason. Screens will
become restricted and cause unsafe furnace operation.
Accessories are being marketed for RV products which we do not
recommend. For your safety, only factory authorized parts are to
be used on your furnace.
WARNING
FIRE OR EXPLOSION
•
DO NOT alter the furnace to a positive grounding system.
•
DO NOT use battery charger to supply power to DC model
furnaces even when testing.
•
DO NOT connect 120 VAC to 12 VDC furnaces.
WARNING
POSSIBLE INJURY OR DEATH
If the user of this appliance fails to maintain it in the condition in
which it was shipped from the factory or if the appliance is not
used solely for its intended purpose or if appliance is not
maintained in accordance with the instructions in this manual, then
the risk of a fire and/or the production of carbon monoxide exists
which can cause personal injury, property damage or loss of life.