P1512137 R3
11
2.9. Raising and Lowering the Conveyor
• Before raising/lowering/moving/adjusting the conveyor, make sure the area around the
conveyor is clear of obstructions and/or untrained personnel. Never allow anyone to stand
on or beneath the conveyor when it is being placed.
• Lower the conveyor to its lowest position when not in use.
• Empty the conveyor before raising or lowering.
• Do not get on or beneath the conveyor when raising or lowering.
• Raise and lower conveyor on reasonably level ground only.
• Never attempt to increase height of the tube by positioning wheels on lumber, blocks, or by
any other means. To do so will result in damage to conveyor and/or serious injury.
• Do not raise the conveyor in high winds.
2.10. Positioning the Conveyor
• Transport and place equipment on reasonably level ground when raising, lowering,
positioning, or operating.
• Move the conveyor into position slowly. Do not unhitch and attempt to move by hand.
• Chock wheels and anchor intake end after placement.
2.11. Towing the Conveyor
The conveyor is not intended for transport on public roads. If it requires transport on a public roadway, the
following steps should be taken:
• Check with local authorities regarding transport on public roads. Obey all applicable laws
and regulations.
• Always travel at a safe speed, never exceeding 20 mph (32 km/h).
• Reduce speed on rough surfaces.
• Do not transport on slopes greater than 20°.
• Use caution when turning corners or meeting traffic.
• Make sure the SMV (slow moving vehicle) emblem and all the lights and reflectors that are
required by local authorities are in place, are clean, and can be seen by all over-taking and
oncoming traffic.
• Always use hazard-warning flashers on tractor/towing vehicle when transporting unless
prohibited by law.
• Do not allow riders on the conveyor or towing vehicle during transport.
• Attach to towing vehicle with an appropriate pin and retainer. Always attach safety chains.
• Place the conveyor in the transport position before moving on roads.
S-DRIVE STANDARD CONVEYOR – PORTABLE GRAIN BELT CONVEYOR
