![background image](http://html1.mh-extra.com/html/xantrex/tr1512-120-60/tr1512-120-60_installation-manual_3342691023.webp)
P
r
e
-
i
n
s
ta
ll
at
i
on
P
l
a
nn
i
ng
975
-
0367
-
01
-
01
1
–
5
This manual for use by qualified installers only
H
a
r
d
wa
r
e
/
Ma
t
e
r
i
a
l
s
R
e
q
u
i
r
e
d
The following hardware or materials may be required to complete this installation.
❐
4 ft. x 4 ft. (1.22 m x 1.22 m) sheet of
¾
in. (20 mm) plywood or equivalent;
or standard construction stud material, for example 2 ft. x 4 ft. (60 cm x
120 cm)
❐
#12 wood screws or
¼
in. x 1
½
in. (6.5 mm x 38 mm) lag bolts or equivalent
❐
Conduit and appropriate fittings
❐
Wire nuts
W
i
r
i
n
g
C
o
n
s
i
d
e
r
a
t
i
o
n
s
This section describes the wiring requirements and considerations. It provides the
required wire sizes, recommended lengths for conductors, and disconnect/circuit
breaker requirements. All wiring should be made with minimum 90° C copper
wire. While 90°C or higher temperature rated wiring may be used, the wire gauge
sizing must still be based in accordance with 75°C wiring ampacities from your
local electrical code for use in conjunction with typical AC over-current
protection. See “Minimum Recommended Battery Cable Size versus Length” on
page 2–8 for details.
All wiring and installation methods should conform to applicable electrical and
building codes.
Pre-plan the wire and conduit runs.
•
The AC terminals accept cable sizes up to #6 AWG (13.6 mm
2
).
•
The DC terminals accept any size cables that use ring terminals with 5/16 in.
(8 mm) holes and a maximum flange width of 1 5/16 in. (33 mm).
•
If you intend to stack two 120 V/60 Hz units, consider the length of the
provided series stacking cable (3 ft./0.9 m).
•
Due to voltage drop considerations, battery-to-inverter cabling should be only
as long as required. See Table 2-4, “Minimum Recommended Battery Cable
Size versus Length” on page 2–8 to assist you with cable sizing and length.
For maximum safety, run both AC and DC cables in conduit.
http://www.wholesalesolar.com/inverters.html
http://www.wholesalesolar.com/inverters.html
Summary of Contents for TR1512-120-60
