Thetford SANICON TURBO 300, Operating Instructions Manual

Page: 7 / 25

Sani-Con Model 300 - Portable Tank “Buddy”
7
www.thetford.com
Cautions and Warnings
Read and understand the warnings and cautions listed in this
document before you operate, or service this unit.
Congratulations on your purchase of the Sani-Con® 300 - the
cleanest, most sanitary, and convenient way to empty your RV
holding tank!
Thetford Corporation accepts no responsibility or liability for
damage to equipment, injury, or death that may result from the
system’s improper installation, service, or operation.
Thetford Corporation recommends that plumbing and electrical
work be performed by a licensed tradesperson. Local permit and
code compliance is required.
■
Flush only organic human waste and toilet tissue.
Do not flush non-dissolving articles such as feminine
hygiene products, paper towels, or moist towelettes,
as this will damage the macerator and will
void your
warranty .
■
To avoid pump failure, if you are using an accessory
garden hose on the end of the nozzle, make sure
that the inner diameter of the hose is .75 “ (1.9 cm) or
greater.
Questions?
If you have any questions or need assistance, please contact
Customer Service at 1-800-543-1219, available Monday through
Friday 8 a.m. to 6 p.m., Eastern Standard Time.
Read and understand the warnings listed in this docu-
ment before you operate or service this system. If you do
not obey these warnings there is a risk of property loss,
injury, or electrocution. Do not make any changes to this
unit as this could result in property damage, injury, or
electrocution.
NOTICE AVIS AVISO
CAUTION !
ATTENTION
! ATTENTION
ATTENTION
! ATENCIÓN
ATTENTION
! DANGER
Wear appropriate personal protective equipment when
using the Sani-Con® system.
NOTICE AVIS AVISO
CAUTION !
ATTENTION
! ATTENTION
ATTENTION
! ATENCIÓN
ATTENTION
! DANGER
Do not make any changes to this unit, as this could
result in property damage or injury.
NOTICE AVIS AVISO
CAUTION !
Overview
Operation
T000081A
To extend the life of the discharge hose
(K2)
,
avoid
sharp bends and stress at hose cuffs and support the
hose within 2”- 5” of cuff
(K2.1)
when in use.
NOTICE
EMPTY BLACK WATER TANK
Refer to Fig. 1 and Fig. 5.
1. ENSURE universal nozzle (
K2
) is securely attached to dump
station! Refer to “Attach Pump to RV” procedure.
2. Open black water tank gate valve (
5B
).
3. Turn pump on.
4. Do not leave unit unattended.
5. Turn pump off.
TIP For Cleaner Storage: Emptying the black water tank
first, allows gray water to cleanse the system.
NOTICE
TIP: The hose expands as fluid moves to dump station
and contracts when tank is empty.
NOTICE
6. Close black water tank gate valve (
5B
).
1. Remove pump
(K1)
from storage box
(K7)
.
2. Remove bayonet cap
(K6)
from the pump
(K1)
.
3. Connect the bayonet adapter
(K1.3)
to the RV’s drain
outlet
(5A)
.
4. Unscrew large nozzle cap
(K2.4)
.
5. Attach universal nozzle
(K2)
to dump station.
Verify SaniCon pump switch is in the off position!
NOTICE AVIS AVISO
CAUTION !
ATTENTION
! ATTENTION
ATTENTION
! ATENCIÓN
ATTENTION
! DANGER
6. Connect pump
(K1)
to the power source
(4A)
with the al-
ligator clips
(K5)
or quick connect
(K3)
, if installed. Using
a 35 AMP, 12 VDC power source:
■
Connect the black alligator clip to the negative post on
the power source.
■
Connect the red alligator clip to the positive post on the
power source.
7. Using the quick connect
(K3)
, plug the pump
(K1)
into
the pre-wired electrical leads (refer to “Connect Electrical -
Quick Connect Option” section).
Attach Pump to RV
Refer to Fig. 1 and Fig. 5.