![background image](http://html1.mh-extra.com/html/taylor-dunn/c0-t50-80/c0-t50-80_service-and-parts-manual_3778350035.webp)
Front Axle
Page 35
MC-T50E-02
C0-T50-80
REPLACE THE STEERING
CYLINDER
This procedure assumes that the front axle has been
removed from the vehicle. Refer to the front axle removal
instructions for details and warnings regarding the
removal and installation procedure.
Remove
1: Disconnect the two hydraulic lines from the
cylinder. Install plugs into the hoses to prevent
hydraulic fluid from bleeding out.
2: Disconnect the rod ends from the cylinder ram.
3: Remove the four bolts holding the cylinder to the
axle beam and remove the cylinder. Discard the
cylinder bolt locking tabs.
Install
1: Using new locking tabs, install the cylinder onto
the axle beam. Tighten the bolts per torque listed
in the Hardware Torque table at the end of this
section.
2:
Bend the locking tabs up against one flat on each
bolt.
3: Connect both hydraulic lines to the cylinder and
bleed all air out of the hydraulic system.
4: Install the rod ends and check wheel alignment.
Refer to procedure “Align Front Wheels” for
details.
5: Tighten the rod end pivot pin nuts per torque
listed in the Hardware Torque table at the end of
this section.
This section is one section of a complete service
manual. Before starting any procedure, read all
warnings and instructions that are located in the
Service Guidelines chapter.
WARNING
REBUILD THE STEERING
CYLINDER
Refer to Steering Component Service section
Summary of Contents for C0-T50-80
