TROUBLESHOOTING & REPAIR
53
AVTM21-415Ja Rev. A June 2005
2.
Locate the shield of the output cable and disconnect it
from the chassis.
3.
Carefully unsolder the output cable center conductor from
the shield eyelet.
4.
Mark all leads on the panel terminal strip and disconnect
them.
5.
Locate the four nuts that secure the chassis to the panel;
with the set upright on the chassis remove the nuts, lock
washers and flat washers.
6.
Withdraw the four mounting stud insulating bushings.
7.
Lift the panel off the chassis.
8.
Set aside the insulation spacer blocks that are located
between chassis and panel.
9.
Follow these steps in reverse order for re-assembly.
For Catalog No. 210415-47 Test Sets it is necessary to first
disconnect the test set power cord from the step-down
transformer that is located in the cover.
CHANGING LINE VOLTAGE TAP (-47 MODELS ONLY)
To change the nominal supply voltage on the -47 version,
disconnect the test set from the line. Remove the 4 screws
securing the adaptor to the lid. Re-connect taps per table listed
in schematic and on the adaptor (P/N 22763). Install fuse F1
of correct rating. Complete by re-installing adaptor in lid.
REPLACEMENT OF OUTPUT CABLE W101
It is not necessary to separate panel and chassis for this
operation.
Summary of Contents for ATEC 210415 Series
