Page 9 - 10
TA3H, TA3SH & TA3.5SH
9. Maintenance
(3)
To Drain the Engine Oil
When changing the engine oil the oil filter must be replaced. (Refer to the engine manufacturers
handbook). The engine must be warm when draining the oil.
9.13
Engine Coolant
The cooling system is pressurised to increase boiling point of the coolant and therefore extreme
caution must be taken when performing any maintenance on the cooling system when hot to
prevent scalding.
PROCEDURE
1.
Remove the engine oil filler cap.
2.
Add clean, fresh oil of the correct grade to the engine.
3.
While adding oil, check the level frequently to make sure it does not go over the MAX
level.
4.
When the oil is up to the required level replace the filler cap.
5.
Wipe up any spilt oil.
NOTICE
Do not overfill the engine. Too much engine oil may cause damage to the engine.
PROCEDURE
1.
Park the machine on firm, level ground, apply parking brake, place transmission in
neutral, remove the starter key, set the battery isolator to off and remove the battery
isolator key.
2.
Place a suitable container under the machine and remove the drain plug and allow the old
oil to drain into the container.
3.
When the oil has finished draining, replace the drain plug and securely tighten.
4.
Replace engine oil filter.
5.
Refill engine with the correct grade of oil.
6.
Start the engine and check for any leaks.
b
WARNING
NEVER perform checks or maintenance on the cooling system when it is hot. NEVER remove
radiator cap when engine is hot - severe risk of scalding. NEVER remove radiator cap when the
engine is running. Antifreeze is TOXIC. If accidentally swallowed, medical advice must be
sought Immediately. Antifreeze is corrosive to the skin. If accidentally spilled on to skin, it must
be washed off immediately. Protective clothing and eye protection must be worn when handling
antifreeze.
Summary of Contents for TA3.5SH
