14
7EN150104 Rev. 8
• 2020
www.hillrom.com
Charging the Battery
Indications for charging the battery
In the event of low battery capacity, a signal from the control box will sound and the
indicator (A) on the hand control will light. When this happens, the battery must be
charged as soon as possible. However, there is sufficient power for a few more lifts.
A
Wallmounted charger accessory or table charger housing accessory:
Remove the battery pack from the control box by loosening the locking device on top of the battery pack. See chapter
"Assembly".
Charger information;
"ON" - lights up green when the charger is connected to mains.
"CHARGE" - lights up yellow constantly during charging and will turn off when charging is completed.
Alt. A
. Place the battery pack on the wallmounted charger. Plug the charger cable into mains (100-240 VAC)
check that both "ON" and "CHARGE" on the charger lights up.
Alt. B
. Place the battery pack on the charger in the table charger housing. Plug the charger cable into mains (100-240 VAC)
check that both "ON" and "CHARGE" on the charger lights up.
Alt. A
Alt. B
Alternative charging procedures
ON
CHARGE
ON
CHARGE
Charger information
1. "ON" - lights up green when the charger is connected to mains.
2. "CHARGE" - lights up yellow constantly during charging and will turn off
when charging is completed.
Charging with the control box internal charger (standard)
Plug the charger cable into mains (100-240 VAC), see charger information 1 - 2 above.
The battery is fully charged after about 6 hours and the charger disconnects
automatically, the yellow "CHARGE" diode turn off.
For maximum battery life, batteries must be charged regularly. We recommend
charging after each use or every night.
Never charge batteries in a wet area!
NOTE!
•
If the charger cable (coiled cable) is streched out it should be replaced to avoid the risk of the cable getting caught and tear.
•
The lift cannot be used when the charger cable is plugged into a wall socket.
•
If the yellow "CHARGE" diode at the control box continuos to be lit after 8 hours, discontinue charging and replace the
battery with a new one.
•
A damaged battery shall be replaced and contact with leaking fluids shall be avoided.
•
If the lift is not used every day, we recommend pushing the emergency stop after use, in order to turn off the power and
conserve battery life. Make sure the battery is completely charged before pushing the emergency stop.
•
The lift cannot be charged with the emergency stop activated.
ON CHARGE
EMERGENCY
1.
2.
ON
CHARGE
ON CHA
RGE
EMERG
ENCY
