lancer CENTURIONII 85-0055, Installation And Service Manual

Page: 3 / 40

TABLE OF CONTENTS (CONTINUED)
7. TROUBLESHOOTING...............................................................................................................................15
7.1 NO WATER OR CONCENTRATE ON EITHER SIDE .....................................................................15
7.2 NO WATER OR CONCENTRATE ON ONE SIDE ONLY ................................................................15
7.3 WATER ONLY - NO CONCENTRATE .............................................................................................15
7.4 CONCENTRATE ONLY - NO WATER EITHER SIDE......................................................................16
7.5 CONCENTRATE ONLY - NO WATER ON ONE SIDE ONLY..........................................................16
7.6 NO FLUSH WATER EITHER SIDE, SYSTEM DISPENSES NORMALLY ......................................16
7.7 NO FLUSH WATER - ONE SIDE ONLY, NORMAL DISPENSE BOTH SIDES ...............................16
7.8 WATER DRIPS FROM SPOUT WHEN DRINK IS NOT BEING DISPENSED...............................16
7.9 WATER LEAKING INTO CONCENTRATE CONTAINER AND/OR CONCENTRATE TUBE...........16
7.10 WATER LEAKING INTO CONCENTRATE CONTAINER DURING FLUSH CYCLE .......................16
7.11 AIR LEAKING INTO CONCENTRATE TUBE AND/OR CONCENTRATE PUMP............................16
7.12 RATIO CANNOT BE ADJUSTED LOW ENOUGH (OR
o
BRIX HIGH ENOUGH)............................17
7.13 RATIO CANNOT BE ADJUSTED HIGH ENOUGH (OR
o
BRIX LOW ENOUGH)............................17
7.14 RATIO (
o
BRIX) VARIES FROM DRINK TO DRINK .........................................................................17
7.15 CONCENTRATE LOW LEVEL INDICATOR ON BUT CONCENTRATE CONTAINER IS FULL .....17
7.16 WATER CONTINUALLY OVERFLOWS FROM ICE BANK COMPARTMENT INTO
CONCENTRATE COMPARTMENT AND INTO DRIP TRAY ...........................................................17
7.17 COMPRESSOR STARTS AND CONTINUES TO RUN UNTIL FREEZE UP AND
WILL NOT CUT OFF........................................................................................................................18
7.18 WARM DRINKS................................................................................................................................18
7.19 COMPRESSOR DOES NOT START (NO HUM), CONDENSER FAN MOTOR
DOES NOT RUN AND NO ICE BANK.............................................................................................18
7.20 COMPRESSOR DOES NOT START (NO HUM), NO ICE BANK, BUT
CONDENSER FAN MOTOR RUNS.................................................................................................18
7.21 COMPRESSOR DOES NOT START, BUT HUMS ..........................................................................18
7.22 COMPRESSOR STARTS AND DOES SWITCH OFF OF START WINDING (WILL ONLY RUN
FOR A FEW SECONDS) BEFORE INTERNAL OVERLOAD SWITCHES COMPRESSOR...........18
7.23 COMPRESSOR STARTS AND RUNS A SHORT TIME, BUT SHUTS OFF ON OVERLOAD ........19
8. TROUBLESHOOTING USING PCB 12 VOLT (GREEN), MOTOR OVER CURRENT (YELLOW)
AND MOTOR (RED) DIAGNOSTIC LIGHTS ............................................................................................20
9. INSTALLATION OF PUSHBUTTON KITS FOR CENTURION II..............................................................21
10. CENTURION PUSHBUTTON SERVE/FLUSH SWITCH INSTALLATION ...............................................22
10.1 INSTALLATION ................................................................................................................................22
10.2 FLUSHING CENTURION.................................................................................................................23
11. ILLUSTRATIONS, PARTS LISTINGS, AND WIRING DIAGRAMS ......................................................... 24
11.1 CENTURION II - FINAL ASSEMBLY ..........................................................................................24-25
11.2 CENTURION II - PUMP REGULATOR ASSEMBLY...................................................................26-27
11.3 CENTURION II - WATER/CONCENTRATE COMPONENT ASSEMBLY ...................................28-29
11.4 CENTURION II - REFRIGERATION ASSEMBLY .......................................................................30-31
11.5 CENTURION II - AGITATOR DECK ASSEMBLY.............................................................................32
11.6 CENTURION II - WIRING CONNECTIONS.....................................................................................33
11.7 CENTURION II - WIRING DIAGRAM ..............................................................................................34
ii