![background image](http://html2.mh-extra.com/html/l-b-white/aw060/aw060_owners-manual-and-instructions_3104826047.webp)
Guardian Agricultural Animal Confinement Building Heaters
Owner’s Manual • Guardian
7
■ LPG and natural gas have a distinctive odor. Learn
to recognize these odors. (Reference “Fuel Gas
Odor” and “Odor Fading” sections above.
■ If you have not been properly trained in repair and
service of LPG and natural gas brood heaters,
then do not attempt to light brood heater, perform
service or repairs, or make any adjustments to the
brood heater on LPG or natural gas fuel systems.
■ Even if you are not properly trained in the service
and repair of the brood heater, ALWAYS be con
-
sciously aware of the odor of LPG and natural gas.
■ A periodic “sniff test” around the brood heater or
at the brood heater’s joints; i.e. hose, connections,
etc., is a good safety practice under any conditions.
If you smell even a small amount of gas, CONTACT
YOUR FUEL GAS SUPPLIER IMMEDIATELY. DO
NOT WAIT!
Safety Precautions
1. Do not attempt to install, repair, or service this
brood heater or the gas supply line unless you
have continuing expert training and knowledge of
gas brooder heaters.
Qualifications for service and installation of this
equipment are as follows:
a. To be a qualified gas brood heater service
person, you must have sufficient training and
experience to handle all aspects of gas-fired
brood heater installation, service and repair.
This includes the task of installation, trouble
-
shooting, replacement of defective parts and
testing of the brood heater. You must be able
to place the brood heater into a continuing
safe and normal operating condition. You must
completely familiarize yourself with each model
brood heater by reading and complying with the
safety instructions, labels, Owner’s Manual, etc.,
that is provided with each brood heater.
b. To be a qualified gas installation person, you
must have sufficient training and experience
to handle all aspects of installing, repairing
and altering gas lines, including selecting and
installing the proper equipment, and selecting
proper pipe and tank size to be used. This must
be done in accordance with all local, state and
national codes as well as the manufacturer’s
requirements.
2. All installations and applications of L. B. White
brood heaters must meet all relevant local,state,
and national codes. Included are applicable fuel
gas systems, gas installation, electrical, and
safety codes. Your local fuel gas supplier , a local
licensed electrician, the local fire department or
similar governmant agencies, or your insurance
agent can help you determine code requiremenjts.
3. Do not move, handle, or service the brood heater
while in operation or connected to a power or fuel
supply.
4. This brood heater may be installed in areas
subject to washdown. This brood heater may only
be washed on the external case assembly—see
Cleaning Instructions. Do not wash the interior
of the brood heater. Use only compressed air,
soft brush or dry cloth to clean the interior of the
brood heater and it’s components. After external
washdown, do not operate this brood heater until it
is completely dry. In any event, do not operate the
brood heater for at least one hour after external
washdown.
5. For safety, this brood heater is equipped with a
manual reset high-limit switch and an air flow
switch. Never operate this heater with any safety
device that has been bypassed. Do not operate
this brood heater unless all of these features are
fully functioning.
6. Do not operate the brood heater with its door(s)
open or panel removed.
7. Do not locate fuel gas containers or fuel supply
hoses within 6,10 meters of the blower outlet of the
brood heater.
8. Do not block air intakes or discharge outlets of the
appliance. Doing so may cause improper combus
-
tion or damage to brood heater components
leading to property damage or animal loss.
9. The hose assembly shall be visually inspected on
an annual basis. If it is evident there is excessive
abrasion or wear, or if the hose is cut, it must be
replaced prior to the brood heater being put into
operation. The hose assembly shall be protected
Attention - Critical
Points to Remember!
Summary of Contents for AW060
