Guardian Agricultural Animal Confinement Building Heaters
www.lbwhite.com
Owner’s Manual • Guardian
12
Assemble the tee, nipples and cap together and
tighten securely. The sediment trap assembly must
always be mounted in a vertical position. Use pipe
thread compound that is resistant to LPG. Check all
connections for gas leaks using approved gas leak
detectors.
FIG. 4
NIPPLE
TEE
NIPPLE
CAP
TO GAS CONTROL
VALVE INLET
Thermostat Installation
(Must be ordered separately)
To Connect the Direct Wired Thermostat Kit to the
Control Box on the Brood Heater:
■ The installation and wiring of a thermostat must
be done by an electrician or someone properly
qualified.
a. Open the control box.
b. Remove the yellow wire connected between
the 24 volt output of the transformer and termi
-
nal W of the ignition control.
c. Remove the plastic hole plug at the back or
bottom of the control box. Run the wiring of the
thermostat kit through this hole.
d. Connect the black lead of the thermostat kit to
the 24 volt output terminal of the transformer.
Sediment Trap Assembly
WARNING
Electrical Shock Hazard
■ Disconnect the electrical supply before con
-
necting the thermostat to the brood heater.
■ Failure to follow this warning can result in
electrical shock, leading to personal injury
or death.
e. Connect the white lead of the thermostat kit to
terminal W of the igntion control.
f. Install the strain relief (supplied on thermostat
cordset) around the cord at the entry hole of
the control box.
g. Close and latch the control box.
h. Start the brood heater and check for proper
operation.
Manual Shut-off Valve,
Hose & Regulator
Assembly
(Must be ordered separately)
1. Always use approved pipe thread compound
suitable for use with LPG on the threaded con
-
nections.
2. Assemble the components together according
to the figure. This view is to show general as
-
sembly of the components only.
3. Tighten all connections securely.
4. Check all connections for gas leaks
using approved gas leak detectors.
FIG. 5
REGULATOR
NIPPLE
VALVE, MANUAL
SHUT-OFF
GAS HOSE
ADAPTER
SEDIMENT TRAP
TO CONTROL
VALVE INLET
REGULATOR VENT
GAS FLO
W
Summary of Contents for AW060
