Kolpin Powersports 180??, Service Manual

Page: 72 / 87

70
FIG-19. Electric System
BATTERY CAUTION
The battery gives off explosive gases; keep sparks,
flames and cigarettes away. Provide adequate
ventilation when charging or using the battery in an
open area. The battery contains sulfuric acid
(electrolyte). Contact with skin or eyes may cause
severe burns. Wear protective clothing and a face shield.
Electrolyte is poisonous. Drink large quantities of
water or milk and call a physician if swallowed
BATTERY VOLTAGE INSPECTION
Battery is under the seat; you can see this battery after
removing the seat.
Measure the battery voltage using a voltmeter
(Photo 1)
VOLTAGE: Fully charged: 13.1 V
Undercharged : Below 12.0 V
BATTERY REMOVAL
Remove the seat, and then you can see the battery.
Disconnect the negative cable and then the position
cable and remove the battery.
BATTERY INSTALLATION
Install the battery in the reverse order of removal. Apply
clean dielectric grease to the battery terminals.
CHARGING
Connect the charge positive cable to the battery positive
terminal. Connect the charge negative cable to the
battery negative terminal. Using 0.9A charging current
about 5 hours. (Normal charging) Or using 4A charging
current about 1 hour. (Quick charging) Keep flames and
spark away from a battery being charged. Quick
charging should be limited to an emergency; normal
charging is preferred.
(Photo 2)