IAME Parilla Leopard TaG Series, Assembly Instructions & User Manual

Page: 44 / 46

MAN­048 ING 42
19­ TROUBLESHOOTING
Below are some common faults, their probable causes and suggested remedy:
FAULTS PROBABLE CAUSES REMEDY
Starter will not crank when
turning the key to RUN position
Bad connections on starter cables. Check and tighten
Bad grounding Check connections and tighten.
Interruption on fuse Replace 5A strip fuse, after
checking for eventual reversal of
battery polarity.
Damaged cables Replace
Battery connections loose Check and tighten
Battery discharged Recharge battery
Starter failure Overhaul starter
Relay failure Replace relay
Electronic box
Apply to Authorized Service
Centers
Starter cranks but engine won’t
start when turning the key in
RUN position
Bad cable connections Check connectors
Bad H.T. coil connection or coil
failure Check/Replace
Bad H.T. coil grounding Check grounding
Electronic box or ignition failure Apply to Authorized Service
Centers
Wet spark plug Replace
Malfunction on induction system Check status and connection on
fuel pipe
Replace gaskets and membranes
on carburetor
Check reed petals. Replace if
necessary
Engine starts but it stops after a
few seconds when turning the
key in RUN position Bad cable connections Check stator connector
Electronic box or starter failure Apply to Authorized Service
Centers
Bad carburetor adjustment
( I screw)
Check carburetor adjustment (see
sect. 5)
The starter cranks also after the
engine is running. Electronic box failure Apply to Authorized Service
Centers
Rough idle
Bad carburetor adjustment
(
L screw)
Check carburetor adjustment (see
sect. 5)
Drop in engine performance Bad compression Check piston
Bad carburetor adjustment Check carburetor adjustement
(see sect. 5)
Insufficient gas flow Check fuel flow lines and inlet filter
Dirty inlet silencer Check and clean
Burning smell, smoke
Overheating of clutch Check clutch (see sect. 11)
Clutch engages at too high RPM Excessive wear of friction material Check clutch (see sect. 11)
Exhaust too noisy
Flexible damaged Check and replace if necessary
Springs damaged or lost
Insulating strap damaged or lost
Damaged exhaust header