Haojue HJ110-5 99011H53150H000 V01 EN 2016-5-27
(49)
of storage, 3–5 hour charging is necessary.
1.2 Installation
1.2.1 Connect positive terminals “+” (with a red mark) first
and then negative terminals “-”.
Note: please note that
reversing the wires
can damage the electric components
such as the igniter device and the rectifier.
1.2.2 After tightening the bolts, apply grease or jelly to
bolts, nuts and terminals to prevent poor contact due to
rustiness.
2. USAGE AND MAINTENANCE
2.1 Each starting should not exceed 5 seconds. In case
starting is not effected, fuel supply, starting and ignition
systems should be checked.
2.2 The following cases shall result in excessive storage
battery discharging or insufficient charging and shall
shorten service life.
•
Frequent starting and short distance riding;
•
Low-speed riding for a long time;
•
Brake light kept lit due to tight gripping of brake lever
or brake pedal treading;
•
Extra electric elements installed or high-power bulbs
used.
2.3 In case of difficult starting, dim light or horn sounding
not loud and clear, perform immediate charging.
2.4 If your motorcycle is to be stored for a Long time,
charge the battery before storage and charge it every 3
months.
2.5 Charging
2.5.1 Use motorcycle battery special charger.
When
charging, do not remove the sealing cap. Keep the room
well ventilated and
free from flame
.
2.5.2 There are standard charging and quick charging.
In order to prolong service life of battery, use standard
charging unless in case of emergency.
Standard charging: current: 0.4A, time: 5 hours;
Quick charging: current: 3A, time: 1 hour.
Perform charging in strict accordance with the specified
current and time without any increase, or else storage
battery shall be damaged.
3. PRECAUTIONS
3.1 In no case should the sealing cap be removed, nor
should electrolyte or water be added.
3.2 When using or charging battery,
stay off the flame,
avoid positive or negative electrode short circuit and
loosening of positive or negative terminals so as to
prevent battery explosion.
3.3 Electrolyte contains strong acid. Avoid it splashing
onto your skin, clothing or into your eyes. Once it occurs,
wash it off immediately with plenty of clean water. Should
you drink it by mistake, drink plenty of water or milk and
go to hospital for treatment.
3.4 Keep electrolyte out of the reach of children.
3.5 Installation of anti-burglar alarm will also affect the
battery.
It is suggested to use an anti-burglar alarm
recommended by Haojue, other alarms may lead to
48
Haojue HJ110-5 99011H53150H000 V01 EN 2016-5-27
(49)
