3
THE EVOLUTION OF PORTABLE OUTDOOR COOKING
IMPORTANT SAFETY INSTRUCTIONS
IMPORTANT:
Read the safety precautions of this booklet carefully before removing the barbecue from its
carton or connecting the barbecue to its gas supply. If you are unsure about anything regarding
your barbecue, please contact Everdure in Australia on 1300 766 066 or in New Zealand on
(09) 415 6000 before operating your appliance.
1.
This portable barbecue and trolley set are intended for OUTDOOR USE ONLY. This appliance must NOT be used indoors.
2.
For your safety and enjoyment, read all operating instructions before lighting.
3.
Ensure that all gas connections are tight before operating this appliance (refer to leak testing procedure in this manual). Always
check for leaks when a gas cylinder is replaced or reconnected.
4.
Unsupervised children or pets should not be near a barbecue while cooking or during warm up or cool down. Ensure children or
pets are kept a distance well away from the barbecue whilst it is in use. Ensure that young children do not play with the appliance.
This appliance is not intended for use by young children or infirm persons.
5.
Particular care must be taken when removing the fat tray and the disposable foil trays. Mishandling of hot oil and fats can cause
serious injury. Take care when changing plates & grills that parts are not hot & oil or fat does not drop onto the burner. Always
push the cast plates/grills together to minimise any fat dripping onto the burners and do not cook food over the gap between
plates. Take care that the burner ports do not block up.
6.
Turn gas valve/control knob and gas cylinder valve off after use. Do not allow build up of unburned gas.
7.
Do not use this appliance for any purpose other than what it is intended for.
8.
Do not move this barbecue set while in use or directly after use, as accessible parts may be very hot. The barbecue should only be
lifted by the serverys at either side (the fold out servery bins should be either folded in or removed). Take care that undue pressure
will not be placed on the gas hose, or turn off the gas supply & remove the hose from the cylinder or gas source (not at the
barbecue). Take care that the fat tray & disposable foil tray are removed to minimise fat/oil spillage. When moving on the trolley,
leave the gas cylinder in the cylinder mounting for stability and to hold the mounting in place.
9.
This barbecue has been designed to be used either on a raised bench or supplied trolley Stand. When using a raised surface (table
etc.), ensure the surface is level, large enough and strong enough to support the barbecue and will withstand temperatures of 60°C
above ambient temperature. When using the trolley, ensure that your barbecue is in a level position and the barbecue is secured
onto the trolley correctly.
10.
People with flammable clothing such as nylon etc. should keep well away from the barbecue when it is operating.
11.
Never leave the burner on high for more than 10 minutes unless actually cooking.
12.
In case of fat fire turn cylinder off. Fat trays should be cleaned and checked before using the barbecue. Disposable foil trays
should be replaced before using the barbecue. Regular cleaning should reduce the build up of fat and food residues which is
combustible and can result in a fat fire. Fat fires can be prevented with diligence in cleaning your fat tray and regular replacement
of foil trays. Do not allow the foil tray to overflow. Damage as a result of fat fire is not covered by your warranty and voids it. Do
not use sand or kitty litter in the fat tray or disposable foil tray. Fat absorbents (available from your place of purchase) may be used
at the supplier’s & user’s discretion. Everdure recommends using no more than 1cm of the fat absorbent in the foil tray, replacing
after every cooking session to minimise the likelihood of fat fires & takes no responsibility for damaged caused by the use of such
products.
13.
Ensure that the product has adequate clearance from combustible materials. The appliance is designed so that heat will not affect
the stand. All combustible materials must be kept more than 250mm from the sides and rear of the barbecue and more than
1500mm above the cooking surface of the barbecue.
14.
If the burner makes a hissing sound when lit, it may be burning inside. Turn the burner off, allow to cool, and try ignition again.
Keep your barbecue protected against strong wind – if this cannot be avoided, always check that the burners remain alight if
operating the barbecue in windy conditions.
15.
Do not carry out any servicing on the gas manifold of the barbecue yourself – this must only be done by authorised technicians.
16.
We recommend that you regularly maintain your barbecue and keep it in good condition. This can be achieved by following the
cleaning and maintenance suggestions in this booklet.
17.
The barbecue and trolley are designed to be used with either 4kg or 9kg gas cylinders. When not using the trolley, the cylinder
should be placed at a lower level to the barbecue, as far away as the hose will allow without undue tension on the hose, in a
protected spot (so it does not receive any fat splatter from cooking or can be accidently knocked over). When using the trolley, the
gas cylinder should be placed in the dedicated cylinder mounting at the bottom of the trolley, not beside it.
18.
This appliance is not suitable for mounting in a movable vehicle (boat, trailer etc).
19.
Do not use or store this appliance in areas of high salt content (a marine environment) or an area with caustic fumes or liquids
(such as a domestic pool), as these chemicals can cause the appliance materials to deteriorate (and void the warranty). Regular
cleaning and covering with an Everdure barbecue cover can help can help to reduce this.
DO NOT OPERATE THIS APPLIANCE BEFORE READING THE INSTRUCTION BOOKLET
DO NOT PLACE ARTICLES ON OR AGAINST THIS APPLIANCE
DO NOT
STORE CHEMICALS OR FLAMMABLE MATERIALS OR SPRAY AEROSOLS NEAR THIS APPLIANCE
DO NOT
OPERATE THIS APPLIANCE INDOORS
DO NOT
ENCLOSE THIS APPLIANCE. THE MINIMUM CLEARANCE FOR THIS UNIT IS 1500mm ABOVE THE
COOKING SURFACE AND 250mm FROM ANY SIDE
DO NOT
LIGHT WITH HOOD DOWN
DO NOT
OVER-FILL FOIL TRAY WITH FAT ABSORBENTS (1CM MAX). CHANGE AFTER EVERY USE
3
