ECR International Dunkirk DCB-100, Installation, Operation & Maintenance Manual

Page: 10 / 143

6
1 - IMPORTANT INFORMATION
CAUTION
Indicates a hazardous situation which, if not avoided,
could result in minor or moderate injury.
! !
WARNING
Indicates a hazardous situation which, if not avoided,
could result in death or serious injury.
!
DANGER
Indicates a hazardous situation which, if not avoided,
WILL result in death or serious injury.
!
This is the safety alert symbol. Symbol alerts you to
potential personal injury hazards. Obey all safety messages
following this symbol to avoid possible injury or death.
Become familiar with symbols identifying potential hazards.
Boiler installation shall be completed by qualified agency. See
glossary for additional information.
1. Safety Information
WARNING
Do not tamper with or use this boiler for any purpose
other than its intended use. Failure to follow these
instructions could result in death or serious injury.
Use only manufacturer recommended parts and
accessories.
!
CAUTION
Laceration, burn hazard. Metal edges and parts may
have sharp edges and/or may be hot. Use appropriate
personal protection equipment to include safety
glasses and gloves when installing or servicing this
boiler. Failure to follow these instructions could result
in minor or moderate injury.
! !
NOTICE
Used to address practices not related to personal
injury.
WARNING
Fire, explosion, asphyxiation and electrical shock
hazard. Improper installation could result in death or
serious injury. Read this manual and understand all
requirements before beginning installation.
!
WARNING
Fire, Explosion, Asphyxiation, Electrical shock hazard!
Flooding will result in damages such as electrical
problems, corrosion, inoperative parts, mold and other
unforeseen issues which can occur over time. Any
equipment determined by a professional as damaged
by a flood, defined as excess of water or other liquid,
shall be replaced. Failure to follow these directions will
result in a Hazardous Situation.
!
FOR YOUR SAFETY READ BEFORE OPERATING
DANGER
!
Water
Temperature
Setting
1st Degree Burn
Exposure Time For
An Adult
2nd and 3rd Degree Burn
Exposure Time For An
Adult
120° F 1 minute 5 minutes
130° F 5 seconds 30 seconds
140° F 2 seconds 5 seconds
150° F 1 second 1.5 seconds
160° F Instantaneous 0.5 seconds
Note: Warning for Infants, Children, and Elderly:
Great care must be taken when exposing the
aforementioned groups to warm or hot water as they
can be badly burned in exposure times less than half
of the time for an adult.
Hot Water Can Scald
!
Water heated to temperature for clothes washing,
dish washing and other sanitizing needs can scald and
cause permanent injury.
Children, elderly, and infirmed or physically
handicapped persons are more likely to be
permanently injured by hot water. Never leave them
unattended in bathtub or shower. Never allow small
children to use a hot water tap or draw their own
bath.
If anyone using hot water in the building fits the
above description, or if state laws or local codes
require certain water temperatures at hot water taps,
you must take special precautions:
• Use lowest possible temperature setting.
• Install some type of tempering device, such as
an automatic mixing valve, at hot water tap or
water heater. Automatic mixing valve must be
selected and installed according to manufacturer's
recommendations and instructions.
• Water passing out of drain valves may be
extremely hot. To avoid injury:
• Make sure all connections are tight.
• Direct water flow away from any person.
240013501 REV A [03/15/2022]