50 Hz: G625 - G690 - G750XW/XF
OPERATION & MAINTENANCE MANUAL
13
60 Hz: G655 - G750 - G800 - G850XW/XF
SAFETY INSTRUCTIONS
DANGER
This machine is not designed for operating life-
sustaining equipment. It is equipped with a safety
shutdown system that will cause the machine to stop
operating whenever a shutdown condition is present.
Never operate the machine inside a building without
adequate ventilation. Avoid breathing exhaust fumes
when working on or near the machine.
WARNING
A battery contains sulfuric acid and can give off
gases which are corrosive and potentially explosive.
Avoid contact with skin, eyes, and clothing. In case
of contact, flush area immediately with water.
WARNING
Improper operation of this equipment can cause
severe injury or death. Read the Operation &
Maintenance manual supplied with this machine
before operation or service.
Modification or alteration of this machine CAN result
in severe injury or death. Do not alter or modify this
machine without the express written consent of the
manufacturer.
WARNING
This machine is equipped with an Auto Start System,
which can cause the machine to start at any time.
Follow all safety recommendations outlined in this
manual to avoid injury to personnel. DISCONNECT
BATTERY BEFORE SERVICING.
CAUTION
Exercise extreme caution when using booster
battery. To jump battery, connect ends of one booster
cable to the positive (+) terminal of each battery.
Connect one end of other cable to the negative (-)
terminal of the booster battery and other end to a
earth connection away from dead battery (to avoid a
spark occurring near any explosive gases that may
be present). After starting unit, always disconnect
cables in reverse order.
WARNING
Never inspect or service unit without first
disconnecting battery cable(s) to prevent accidental
starting.
Wear eye protection while cleaning unit with
compressed air, to prevent debris from injuring eyes.
WARNING
HOT PRESSURISED FLUID - Remove cap slowly to
relieve PRESSURE from HOT radiator. Protect skin
and eyes. HOT water or steam and chemical
additives can cause serious personal injury.
WARNING
Flammable Fuels - Do not fill tank when engine is
running.
Do not smoke or use an open flame in the vicinity of
the generator set or fuel tank. Do not permit
smoking, open flame, or sparks to occur near the
battery, fuel, cleaning solvents or other flammable
substances and explosive gases.
Do not operate Genset if fuel has been spilled inside
or near the unit.
