DINGO 150, User Manual

Page: 41 / 179

Washing the snowmobile:
While
washing the snowmobile the following details shouldn't be washed with water under pressure - ignition lock, electrical
equipment
switches, a damper out port. This may damage them.
After cleaning the snowmobile wash it with clean water. Wipe the snowmobile dry. Start the engine and let it work for several
minutes.
Stand-by storage of the snowmobile:
In condition of long storage, for example in summer (more than one month)
take measures for keeping the snowmobile in good condition. Perform its
maintenance.
Wash the snowmobile and wipe it dry. Rub painted
metallic details with a wax. Drain fuel from tank and carburetor. Take off the spark
plug. Fill to a cylinder a small amount of motor oil (15-20 ml) of the same type that is
filled to the engine, slowly rotate the shaft by 1-2 rotations and put the plug on its
place.
Disconnect an accumulator battery. When taking the accumulator off first
disconnect the negative conductor, then a positive one. Keep it in
a dark, cool, and well aired room. When installing
first connect the positive conductor, then a negative one.
Water should be removed from crank chambers of a front suspension, the track block frame, seat frame. It is also necessary to
remove water and replace a lubricant in track block bearings.
Cover the snowmobile with a cover or a material not letting air in. Store your snowmobile in an aired room not accessible for rain,
direct sunbeams and without big heat differences. In a period of a long storage
the snowmobile should be humped up, the track should be weakened and shouldn't touch surface. It will be also useful to turn the
track over by two-three rotations not rarer than once a month.
Snowmobile operating after storage:
Take off the cover and clean the snowmobile from a storage material. Check accumulator voltage. Recharge it
if voltage is lower than 12.0 volt. Put the accumulator on its place. Fill a fresh fuel.
Before driving examine the snowmobile. Perform a trial run in a safe place to make sure in normal
snowmobile work.
40
WASHING AND STORING