●
The service life of drive chain is
dependent upon proper lubrication and
adjustment. Poor maintenance can cause
premature wear or damage to the drive
chain and sprocket.
●
The drive chain should be checked and
lubricated as part of the Pre-ride
Inspection.
●
Under severe usage, or when the
motorcycle is ridden in unusually dusty
or muddy areas, more frequent
maintenance will be necessary.
<INSPECTION>
1.
Turn the engine off, put vehicle in
upright position on the main stand and
shift the transmission into neutral.
2
.
Remove the chain tensioner.
3
.
Move the position of chain tensioner
roller up and down with hands to check
if the chain free play is within
recommended range.
OPTIMA FREE PLAY : 50~60 mm
4
.
Rotate the rear wheel slowly and inspect
the drive chain and sprockets for any of
the follwing conditions :
■
DRIVE CHAIN
①
Damged rollers
②
Loose Pins
③
Dry or Rusted Link
④
Kinked or Binding Link
⑤
Excessive Wear
⑥
Improper Adjustment
⑦
Missing O-ring
■
SPROCKETS
⑧
Excessively Worn Teeth
⑨
Broken or Damaged Teeth
●
A drive chain with damaged rollers,
loose pins or missing O-ring must be
replaced.
●
A chain which appears dry or shows
sings of rust, requires supplementary
lubrication.
31
DRIVE CHAIN
50~60mm
CHAIN TENSIONER ROLLER
**vl125(~47P)
02.11.5
4:34
PM
페이지31
Summary of Contents for DAYSTAR -
