10-6
520 Express Series
520 Express Series
Electrical Troubleshooting,
General Notes
This owner’s manual is designed for owner
operation of the vessel. If it is necessary to
do detailed electrical troubleshooting,
contact Cruisers Yachts Customer Service
at 1-800-743-3478 and request the
necessary documentation, which could
include schematics and harness drawings.
The primary problem involved in most
troubleshooting involves loss of power to the
individual system. This can be caused
because a circuit breaker is tripped. These
circuit breakers can be identified and located
in
Section 5
. If a circuit breaker is tripped it
can be reset. If the circuit breaker trips
immediately after being reset it is an
indication that the circuit is overloaded. In
this case it is necessary to determine the
cause of the fault and to remove the cause
of the fault before resetting the circuit
breaker again. This determination should be
done by a qualified service technician.
Contact the Customer Service Department
at Cruiser Yachts if electrical documentation
is needed.
Plumbing
NOTE
For any troubleshooting information
other than given here, refer to the
individual components owner’s
manuals in the Skipper’s Kit.
CAUTION
DO NOT reset a circuit breaker
which has been automatically
tripped without first locating and
correcting the problem.
PROBLEM
POSSIBLE CAUSE
SOLUTION
No water from cockpit washdown
when turned on
Seacock is closed.
WASHDOWN PUMP circuit breaker
tripped or OFF position.
Washdown switch is OFF.
Strainer or hull inlet plugged.
Pump’s automatic shut-off is
defective.
Open washdown seacock.
If breaker is tripped, correct the problem and reset; otherwise turn
circuit breaker to ON.
Flip switch to ON.
Clean strainer or remove obstruction from inlet.
Service pump. See Cruisers Yachts Dealer for service.
No water at showers or sinks when
faucets are turned on
Fresh water tank is empty.
FR WATER PUMP circuit breaker
tripped.
Pump is defective.
Fill fresh water tank.
If breaker is tripped, correct the problem and reset.
Service pump. See Cruisers Yachts Dealer for service.
Downloaded
from
Cruisers
Owners
Forum
http://www.CruisersOwnersForum.com
