520 Express Series
8-7
INSPECT PROPELLERS FOR
DAMAGE
1. Check propellers for bends, cracks and
pitting.
2. Do not continue to use badly damaged
propellers. Damaged propellers must be
replaced.
Every 100 Hours
INSPECT FRESH WATER SYSTEM
FOR LEAKS
1. Fill and pressurize fresh water system.
2. Lift engine hatch.
3. Inspect connections at fresh water
reservoir, filter, pump and pressure
accumulator. There should be no signs
of leakage. If leaks are apparent, drain
system and replace defective hoses,
tubes and clamps. See your Cruisers
Yachts Dealer for parts and service.
4. Inspect connections at water heater.
There should be no signs of leakage. If
leaks are apparent, drain system and
replace defective hoses, tubes and
clamps. See your Cruisers Yachts
Dealer for parts and service.
CLEAN BILGE
Refer to BILGE in this section.
Monthly
LUBRICATE AIR HORN
COMPRESSOR
1. The compressor is located behind the
dash panel at the helm.
2. Locate the compressor’s oil feed tube.
RUDDER
BEARING
AND SEAL
CSR173-59
3. Remove feed tube cover, and add 4 to 7
drops of oil.
TEST GFCI OUTLET
1. Provide AC to the yacht with either a
shore power hookup, or the onboard
generator (if installed). Turn the
appropriate breaker(s) on.
2. Turn the outlet circuit breakers ON,
located on the AC master panel.
3. Locate the GFCI circuit breaker.
4. Push the test button on each GFCI
outlet. Power should be interrupted to all
outlets onboard. Press the reset button
to restore power.
CSR164-30A
COVER
FEED TUBE
Downloaded
from
Cruisers
Owners
Forum
http://www.CruisersOwnersForum.com
