Cleanco Compact 45, Owner'S Manual, Page: 5 / 84

4
Dangerous Acid, Explosive Gases!
Batteries contain sulfuric acid. To prevent acid burns, avoid contact
with skin, eyes and clothing. Batteries produce explosive hydrogen gas while being charged. To prevent
a fire or explosion, charge batteries only in well ventilated areas. Keep sparks, open flames, and other
sources of ignition away from the battery at all times. Keep batteries out of the reach of children. Remove
all jewelry when servicing batteries.
Before disconnecting the negative (-) ground cable, make sure all switches are OFF. If ON, a spark will
occur at the ground cable terminal which could cause an explosion if hydrogen gas or gasoline vapors are
present. When disconnecting the battery,
ALWAYS disconnect the negative (-) terminal FIRST.
DO NOT smoke around the unit. Gas fumes may accumulate and be ignited. The battery is also
extremely flammable. This will prevent possible explosions.
DO NOT damage the vehicle in any manner during installation. When routing fuel lines DO NOT
place the hose in any location where damage may occur to the hose or vehicle. Avoid any contact with
moving parts, areas of high temperature, brake lines, fuel lines, muffler, catalytic converter, or sharp
objects.
DO NOT exceed your vehicle’s weight limit.
The console with waste tank and accessories weighs
approximately 800 lbs. Make certain to account for any additional accessories in your weight and balance
calculations. Make certain that the vehicle has the correct axle rating. This will prevent unsafe vehicle
driving conditions.
We require high-back seats on all vehicles in which units are to be installed for head and neck
protection.
We recommend using a metal partition between the seats and equipment.
DO NOT operate this unit without the water supply attachment turned on. The water pump and other
vital components may be seriously damaged if this unit is permitted to operate dry without water.
DO NOT operate this unit without the filter installed in the waste tank.
Keep your vehicle work area clean.
Wands, stair tools, and other accessories must be securely
fastened before driving the vehicle.
All high pressure hoses must be rated for 3000 PSI at 250
0
F. Thermoplastic hoses do not meet these
specifications and should not be used. Severe burns and injury may result if the hoses do not meet these
requirements.
Make certain that you receive complete training by the distributor from whom you purchased this
unit.
This unit uses high pressure and temperature. Improper or irresponsible use may result in serious
injury.
Do not modify this unit in any manner.
Improper modification can cause severe personal injury or
fatality.