11
SAFETY TIPS
ALWAYS CHECK FOR LEAKS AFTER EVERY L.P. TANK CHANGE
ALWAYS CHECK FOR LEAKS OF EVERY CONNECTIONS BEFORE EACH USE.
USE LONG BBQ TOOL TO AVOID BURNS.
IF ANY GREASE OR HOT ITEMS FALLING FROM THE GRILL ONTO THE VALVE, REGULATOR, HOSE,
ANYTHING CONVEYING THE GAS, CLOSE THE GAS IMMEDIATELY. CHECK THE CAUSE, AND
REMOVE THE CAUSE. REPERFORM THE LEAK TEST BEFORE CONTINUING.
DO NOT REMOVE THE GREASE TRAY IF THE GRILL HASN’T COMPLETELY COOLED.
CLOSE ALL CONTROL KNOBS AND L.P. TANK VALVE WHEN THE GRILL IS NOT IN USE.
NEVER MOVE THE GRILL WHILE IN USE OR STILL HOT.
PUSH THE GRILL FORWARD, DO NOT PULL WHEN MOVING IT.
DISCONNECTED L.P. TANK IN STORAGE OR BEING TRANSPORTED MUST HAVE A SAFETY CAP
INSTALLED. DO NOT STORE AN L.P. TANK IN ENCLOSED SPACES LIKE CARPORT, COVERED PATIO,
PORCH, GARAGE OR OTHER BUILDINGS.
NEVER LEAVE A L.P. TANK IN A RECREATIONAL VEHICLE OR BOAT WHICH MAY BECOME
OVERHEATED BY THE SUN.
DO NOT STORE L.P. TANK IN OR NEAR AN AREA WHERE CHILDREN PLAY.
DISCONNECTED THE TANK AND REMOVE FROM THE GRILL IF THE GRILL IS STORED INDOORS.
ANY OTHER PROBLEM, SEE “TROUBLESHOOTING” OR CONTACT US FOR ASSISTANCE
.
INSTALLER FINAL CHECK LIST
At least 36” clearance maintained from combustible constructions to the sides and back of this grill.
There is no unprotected combustible construction over the grill.
All internal packaging removed.
Burners are sitting properly on orifices.
Knobs turn freely.
The regulator & hose connected to grill is provided by the manufacturer (pre-set for 11.0” water column).
Unit tested and free of leaks.
User informed of gas supply shut off valve location.
DEAR CONSUMER, PLEASE KEEP THIS MANUAL FOR FUTURE USE.
GRILL LIGHTING INSTRUCTIONS
WARNING: IMPORTANT!
BEFORE LIGHTING:
Finally inspect the gas supply hose before turning the gas “ON”. If there is evidence of cuts, wear, or abrasion, it
must be replaced before use, the replacement hose assembly shall be that specified by the manufacturer.
VERY IMPORTANT: ALWAYS INSPECT THE HOSE BEFORE EACH USE OF THIS GRILL.
TO LIGHT MAIN AND SIDE BURNERS OF THE GRILL:
•
Read instructions before lighting.
•
Turn all knobs to “OFF” then open the L.P. tank valve. Always keep your face and body as far from the grill as
possible when lighting.
•
Open lid during lighting.
•
Push and turn any control knob slowly to “ ” position. , The built-in igniter will click and spark
simultaneously to light the pilot and burner in sequence .Turn the control knob to OFF IMMEDIATELY if the
burner does not light within 5 seconds, wait 5 minutes for gas to dispel, then repeat the lighting procedure.
