BOMBARDIER rally 200, Operator'S Manual

Page: 76 / 130

Reinstall all parts properly in the re-
verse order of removal procedure.
Coolant Replacement
Refer to MAINTENANCE section.
Brake Fluid
Recommended Fluid
Always use brake fluid meeting the
specification DOT 4 only.
CAUTION:
To avoid serious dam-
age to the braking system, do not
use fluids other than the recom-
mended one, nor mix different flu-
ids for topping up.
Fluid Level
With vehicle on a level surface, check
brake fluid in reservoirs for proper
level.
They should be above MIN.
mark.
Add fluid as required. Do not overfill.
Clean filler cap before removing.
CAUTION:
Use only DOT 4 brake
fluid from a sealed container. Do
not use brake fluid taken from old or
already opened containers.
NOTE:
A low level may indicate leaks
or worn brake pads. See an autho-
rized Bombardier ATV dealer.
Brake Lever Fluid Reservoir
Turn steering in the straight-ahead
position to ensure reservoir is level.
Check the brake fluid level, the reser-
voir is full when the fluid reaches of
the top of window.
Visually inspect lever boot condition.
Check for cracks, tears, etc. Replace
if damaged.
V06K05Y
Battery
This vehicle is equipped with an elec-
trolyte type battery that requires a min-
imum of maintenance.
NOTE:
Refer to MAINTENANCE for
removal and installation procedures.
Electrolyte Level
Place the vehicle on a level surface.
Check electrolyte level by the rear
right inner fender. Use a flashlight
if necessary.
Do not use an open
flame.
The electrolyte should be between
lower and upper marks. If level is
low, remove battery from vehicle to
add distilled water.
Refilling
Place battery on a level surface.
Unscrew caps and add distilled water
up to upper mark as required.
Do not
overfill.
_____________________
75