Arctic Cat 2014 XC 450, Service Manual

Page: 104 / 130

101
1. Battery voltage with engine and accessories off
(>12.2 VDC for fully charged).
2. Battery voltage with engine running (charging = 13.8
VDC or greater).
3. Battery voltage with electrical accessories operating,
engine idling (13.5 VDC or greater).
4. Battery voltage starter cranking (10.5-11.5 VDC).
DIAGNOSTIC TROUBLE CODES
(DTC)
If an EFI or related chassis component fails or an
out-of-tolerance signal is detected by the ECM, a diag-
nostic trouble code (DTC) will be generated in the ECM
and displayed on the LCD. The DTC will be displayed
alternately with a wrench icon or malfunction indicator
light (MIL). The DTC will continue to flash, until the
malfunction is corrected and the code cleared.

NOTE: Cycling the ignition (ON, OFF, ON) could
deactivate the DTC until the activating condition
re-occurs.

NOTE: Each of the following numerical codes will
have a one-letter prefix of C, P, or U. A “C” prefix
denotes a chassis malfunction, a “P” prefix
denotes a power train malfunction, and a “U” pre-
fix denotes an Arctic Cat defined message.

NOTE: Normal malfunction codes are cleared from
the LCD when the component is replaced or the mal-
function is corrected; however, intermittent codes
must be cleared as noted in the code chart.
Code Fault Description Possible Cause Fault Recovery
C0063 Tilt Sensor Circuit High Sensor or interconnect harness shorted to battery power Correct condition*
C0064 Tilt Sensor Circuit Low/SG/Open Sensor or interconnect harness open or shorted to chassis ground Correct condition*
P0030 O2 Heater Intermittent/Open Heater or interconnect harness is intermittent or open Correct condition*
P0031 O2 Heater Low/SG Heater or interconnect harness shorted to chassis ground Correct condition*
P0032 O2 Heater High/SP Heater or interconnect harness shorted to battery power Correct condition*
P0107 MAP Sensor Circuit Low/SG/Open Sensor or interconnect harness shorted to chassis ground Correct condition*
P0108 MAP Sensor Circuit High/SP Sensor or interconnect harness shorted to battery power Correct condition*
P0112 Intake Air Temp Sensor Circuit Low/SG Sensor or interconnect harness shorted to chassis ground Correct condition*
P0113 Intake Air Temp Sensor Circuit High/Open Sensor or interconnect harness open or shorted to battery power Correct condition*
P0114 Intake Air Temp Sensor Circuit Intermittent Sensor or interconnect harness intermittent Correct condition*
P0116 ECT Sensor Circuit Range/Performance Sensor producing an out-of-range voltage Correct condition*
P0117 ECT Sensor Circuit Low/SG Sensor or interconnect harness shorted to chassis ground Correct condition*
P0118 ECT Sensor Circuit High/Open/SP Sensor or interconnect harness open or shorted to battery power Correct condition*
P0119 ECT Sensor Circuit Intermittent Sensor or interconnect harness intermittent Correct condition*
P0121 TPS Range/Performance Sensor producing an out-of-range voltage Correct condition*
P0122 TPS Circuit Low/SG Sensor or interconnect harness shorted to chassis ground Correct condition*
P0123 TPS Circuit High Sensor or interconnect harness open or shorted to battery power Correct condition*
P0130 O2 Sensor Intermittent/Open Sensor or interconnect harness intermittent or open Correct condition*
P0131 O2 Sensor Low/SG or Air-Leak Sensor or interconnect harness shorted to chassis ground or an
air-leak exists Correct condition*
P0132 O2 Sensor High/SP Sensor or interconnect harness shorted to battery power Correct condition*
P0171 O2 Feedback Below Minimum Correction Low fuel rail pressure, dirty fuel filter, or dirty injectors Correct condition*
P0172 O2 Feedback Exceeds Maximum Correction Excessive fuel rail pressure, MAP or temp sensors out-of-spec Correct condition*
P0219 Engine Over-Speed Condition Engine speed (RPM) has exceeded the ECM over-speed set-
point/limit Reduce engine speed
P0231 Fuel Pump Relay Circuit Low/SG/Open Relay removed or interconnect harness shorted to chassis ground Correct condition*
P0232 Fuel Pump Relay Circuit High Relay or interconnect harness shorted to battery power Correct condition*
P0233 Fuel Pump Relay Circuit Relay circuit erratic or intermittent Correct condition*
P0261 Cylinder Fuel injector Circuit Low/SG Injector or interconnect harness shorted to chassis ground Correct condition**
P0262 Cylinder Fuel injector Circuit High Injector or interconnect harness shorted to battery power Correct condition**
P0263 Cylinder Fuel injector Balance/Open Injector disconnected or interconnect harness open Correct condition**
P0336 Crankshaft Angle Sensor Synchronization Sensor or interconnect harness intermittent Correct condition**
P0337 Crankshaft Angle Sensor Circuit/SG Sensor or interconnect harness shorted to chassis ground Correct condition**
P0339 Crankshaft Angle Sensor Intermittent/Erratic Sensor or interconnect harness intermittent Correct condition**
P0340 Camshaft Angle Sensor Synchronization Sensor or interconnect harness intermittent Correct condition**
P0341 Camshaft Angle Sensor Circuit/SG Sensor or interconnect harness shorted to chassis ground Correct condition**
P0342 Camshaft Angle Sensor Intermittent/Erratic Sensor or interconnect harness intermittent Correct condition**
P0480 Fan Relay Control Circuit Relay erratic or intermittent Correct condition*
P0484 Fan Relay Control Circuit High Relay or interconnect harness shorted to battery power Correct condition*
P0485 Fan Relay Control Circuit Low/SG/Open Fan fuse has blown, fan relay removed, or interconnect harness
shorted to chassis ground Correct condition*
P0500 Vehicle Speed-Sensor Sensor circuit signal intermittent or missing Correct condition*, start
and drive the vehicle*
P0508 Idle Air Control System Circuit Low/SG IAC interconnect harness shorted to chassis ground Correct condition*
P0509 Idle Air Control System Circuit High/Open IAC disconnected or the interconnect harness shorted to battery
power Correct condition*
P0520 Engine Oil Sensor/Switch Sensor or interconnect harness erratic or intermittent Correct condition*