TGB X-MOTION 250, Руководство пользователя

Страница: 131 / 219

to open inner box lid, then disconnect the battery band
and take out the battery, finally take off cable.
2. Checking electrolyte, add distilled water to refill and
adjust to upper level; in case of adding distilled
water frequently, checking the over- charging of the
battery: No voltage indicated on the terminal or no
action on rectifier, means short on the battery, the
voltage will higher than normal, and the life will
shorten.
3. Inspect charged condition:
Add electrolyte to the upper level and check by
battery hyprometer (as attached drawing). The
density of charged battery must be 1.26~1.28
(above 20°C), if the density below 1.2/20°C, it
means fully dis-charged and must be recharged;
The battery must be checked electrolyte level -
density and the voltage after charging.
5. RECHARGING OF THE BATTERY
To Take off the fixing plugs of the battery before charging. Use 1/10 current intensity of the
capacity to recharge the battery about 15-20 hours at normal condition; connect "+" pole of the
battery to "+" pole of the charger, and "—" with "—". CAUTION:
1. Keep the battery away from flames,sparks, and cigarettes.
2. If the temperature of the electrolyte is higher than 45°C, it must to change to half of the
current intensity or stop to charge until decrease to get under 35°C.
3. After charging the battery, adjusting the electrolyte to upper level and recharge 1-2 hours
again,
then put into the fixing plugs, washing and protect with vaseline.
4. Disassemble the "—" pole terminal at first before taking out the battery from scooter, begin
to assemble the "+" pole terminal reversely.
5. If it couldn't reach to 12v, after charging the battery for 15-20 hours, it's necessary to replace
new battery.
6. REGULAR MAINTENANCE OF THE BATTERY
1. Keep the battery clean and dry.
2. Protect the terminals with vaseline.
3. It can reduce the time to 5-6 hours to charge battery at urgent case.
4. Don't use fuse which above standard, otherwise it'll cause broken of scooter or even firing
5. It must to charge before using new battery to keep the maximum
performance, if don't charging adequately or the electrolyte under the low level, it may cause
broken before normal life.
129
PDF created with pdfFactory Pro trial version www.pdffactory.com