Sakai SV410-2, Руководство оператора

Страница: 47 / 77

– 42 –
Our vehicles are filled with a long-life coolant (non-amine type).
The validity of the antifreezer is for two years.
Use non-amine type long-life coolant when changing coolant.
2.11.3 Battery
WARNING
• Batteries generate explosive gases. Do not use an open flame close to batteries.
• The battery electrolyte is corrosive. Keep the electrolyte away from your eyes and
skin. If you are affected by the electrolyte, flush with large quantities of water and
get medical help.
At low temperature, batteries are less efficient. The level of charge is lowered and batteries
will tend to freeze. Maintain batteries fully charged wherever practicable, and give attention to
heat insulation at night for the next day’s operation.
Check the color of the hydrometer attached to the battery top to charge or replace the battery.
Green
……
Good
Black
……
Discharged too much
White
……
Checking required
Ambient temperature Always
Amount of anti-freeze 6 .5 ℓ (1.7gal)
Amount of water 6 .5 ℓ (1.7gal)
Ratio 50%
– 43 –
2.12 When the Cold Season is Over
When winter is over and the warm season has come, proceed as follows:
1) Change oil and fuel with those for use in warm season referring to “Rating” on page 64.
2) If AF-PT antifreeze is in use, drain the coolant completely, wash clean inside the cooling
system, and then fill with clean water (city water).
2.13 For a Long Storage Period
For leaving the machine unused for longer than one month, proceed as follows:
1) Store the machine in a closed area after cleaning.
2) Conduct oiling, greasing and changing of oil.
3) Grease lubricate the exposed portion of hydraulic cylinder piston rods.
4) Cover the battery after disconnecting the negative cable or take off the battery from the
machine and store in a safe place.
5) If the temperature is expected to go down below 0°C, add antifreeze to the coolant.
6) With F-N-R lever placed at neutral position
Ⓝ
and vibration switch at (OFF) position, have
the parking brake engaged.
7) Chock the machine.
8) Remove the starter switch key.
2.14 During the Storage Period
WARNING
If necessary to operate the machine in indoor storage space, ensure good
ventilation keeping windows and doors open to prevent gas poisoning.
• During storage, operate the machine at least once a month to prevent the oil films on the
lubricated parts from deteriorating and to charge the batteries.
• To prevent the brake linings from sticking to the brake drum, disengage the brake once a
month. Exercise care not to allow the machine to move unexpectedly.