ryan 544915, Руководство по запасным частям и обслуживанию

Страница: 20 / 102

5 MAINTENANCE
20
5.20 STORAGE________________________________________________________________
General
1. Wash the unit thoroughly and lubricate. Repair and
paint damaged or exposed metal.
2. Inspect the unit, tighten all hardware, replace worn
or damaged components.
3. Clean the tires thoroughly and store the unit so the
load is off the tires. If unit is not on jack stands,
check tires at regular intervals and reinflate as
necessary.
4. Keep the machine and all its accessories clean, dry
and protected from the elements during storage.
Never store equipment near an open flame or spark
which could ignite fuel or fuel vapors.
Battery
1. Remove, clean and store battery in upright position in
a cool, dry place.
2. Check and recharge battery every 60 to 90 days
while in storage.
3. Store batteries in a cool, dry place. Do not store on
concrete floor. To reduce the self discharge rate,
room temperature should not be above 80°F (27°C)
or fall below 20°F (-7°C) to prevent electrolyte from
freezing.
Engine (General)
1. While the engine is warm, remove the drain plug,
drain the oil from the crankcase and change oil filter.
Install drain plug and refill with fresh oil. Let engine
cool before storing.
2. Clean exterior of engine. Paint exposed metal, or
apply a light coat of rust preventative oil.
3. Add a fuel conditioner or biocide to prevent gelling
or bacterial growth in fuel. See your local fuel
supplier.
4. If storing indoors, drain fuel from tank.
5. Close fuel shut off valve.
After Storage
1. Check and reinstall battery
2. Check or service fuel filter and air cleaner.
3. Check oil level in the engine crankcase and
hydraulic system.
4. Fill the fuel tank with fresh fuel. Open fuel shut off
valve and bleed the fuel system.
5. Make certain that the tires are properly inflated.
6. Start and operate the engine at 1/2 throttle. Allow
enough time for the engine to become properly
warmed and lubricated.
WARNING
Never operate the engine without proper ventilation;
exhaust fumes can be fatal when inhaled.
!