Oshkosh Corporation JERR-DAN 20NGADF6T-LP, Руководство по эксплуатации и безопасности

Страница: 27 / 112

Section 2 : Pre-Operation and Inspection
5376000207 2-5
1001153789
1001190625
1001190626
478
250 OR
SEMI-
ANNUALLY 1
3
7 HOLD DOWN GUIDE
WINCH GEAR BOX
HYD FILTER OIL
CHECK
CHANGE HYD FLUID
**
---- 2
1
1
1000
OPERATING
HOURS 3
6 WINCH GEAR BOX
HYD RESERVOIR DRAIN/FILL
DRAIN/FILL **
* 1
1
LUBRICATION CHART
CHART COVERS ONLY BODY COMPONENTS * INDICATES DUAL RANGE HYD. FLUID 5 W 20
AUTO TRANS FLUID MAY BE SUBSTITUTED IF NECESSARY ** CONSULT WINCH MANUAL FOR PROPER GRADE AND TYPE
50 OR
MONTHLY 2
4 CABLE
T - HANDLE OIL
OIL ENGINE OIL
ENGINE OIL 1
2
INTERVAL
(HOURS) REF
NO. IDENTIFICATION SERVICE LUBRICANT
DO NOT GREASE SLIDE PADS
NO. OF
POINTS
100 OR
BI-
MONTHLY 1
7 6
2 3
4 5
BIC ROLLBACK CARRIERS
2 6
5 WINCH FS CLEVIS
(IF APPLICABLE)
HYD RESERVOIR
CAM LOCK LUBE CHECK
LUBE MPG *
MPG 1 1
2
478
250 OR
SEMI-
ANNUALLY
1
3
7 HOLD DOWN GUIDE
WINCH GEAR BOX
HYD FILTER OIL
CHECK
CHANGE
HYD FLUID
**
----
2
1
1
1000
OPERATING
HOURS
3
6 WINCH GEAR BOX
HYD RESERVOIR DRAIN/FILL
DRAIN/FILL **
*
1
1
LUBRICATION CHART
CHART COVERS ONLY BODY COMPONENTS
* INDICATES DUAL RANGE HYD. FLUID 5 W 20
AUTO TRANS FLUID MAY BE SUBSTITUTED IF NECESSARY
** CONSULT WINCH MANUAL FOR PROPER GRADE AND TYPE
50 OR
MONTHLY
2
4 CABLE
T - HANDLE OIL
OIL ENGINE OIL
ENGINE OIL 1
2
INTERVAL
(HOURS)
REF
NO.
IDENTIFICATION SERVICE LUBRICANT
DO NOT GREASE SLIDE PADS
NO. OF
POINTS
100 OR
BI-
MONTHLY
1
7 6
2 3
4 5
BIC ROLLBACK CARRIERS
2
6
5
WINCH FS CLEVIS
(IF APPLICABLE)
HYD RESERVOIR
CAM LOCK
LUBE
CHECK
LUBE
MPG
*
MPG
1
1
2
7330000478
REAR VIEW
FIXED HEIGHT FRAME MOUNTED HEADBOARD
TOP VIEW
1001132766
OTHER PATENTS PENDING
UNDER ONE OR MORE OF
THE FOLLOWING PATENTS:
5,133,633 5,575,606
5,697,741 5,722,810
6,315,515 B1 6,336,783 B1
6,447,239 B2 7,264,305 B2
5,951,235 6,231,294 B1
1001132766-A
FOR:
MANUFACTURED BY:
JLG INDUSTRIES, INC.
IDENT. NO.
MODEL
VERSION
MODELNUMBER: SERIAL NUMBER:
MAIN DECK CAPACITY: LBS.*
DO NOT EXCEED THE ABOVE STRUCTURAL RATINGS.
THE MAXIMUM EFFECTIVE TRANSPORT LOAD MAY BE LIMITED BY THE GAWR, GVWR OR GCWR OF THE TRUCK CHASSIS.
THE MAXIMUM EFFECTIVE TRANSPORT LOAD MAY BE LIMITED BY THE RATINGS OF ANY TOW IMPLEMENTS, ATTACHMENTS, OR ACCESSORIES BEING USED.
WHEN SUPPLIED, THE SAFETY LOCKING PIN MUST BE IN PLACE DURING TRANSPORT TO ACHIEVE THE RATINGS LISTED ABOVE.
SAFETY IS NO ACCIDENT. REVIEW OPERATOR'S
PRE-TRANSPORT CHECKLIST ON VEHICLE AND IN THE OWNERS MANUAL EACH TIME YOU MOVE A VEHICLE. FOLLOW ALL INSTRUCTIONS ON CONTROLS AND UNIT.
UPPER DECK CAPACITY: LBS.* WHEELLIFT/TOWBAR LIFT CAPACITY: (FULL EXTENSION)
STRUCTURAL CAPACITIES*
LBS.* WHEELLIFT/TOWBAR TOW CAPACITY: LBS.*
HITCH OPTION TONGUE CAPACITY: (FULL RETRACTION) LBS.*
*PLEASE READ THE FOLLOWING IN ORDER TO ENSURE SAFE AND CORRECT USE OF THE EQUIPMENT.
HITCH OPTION TONGUE CAPACITY:
LBS.*
1001132765-A
13224 Fountainhead Plaza
Hagerstown, MD 21742
Phone (717) 597-7111
www.jerr-dan.com
FOR: MANUFACTURED BY: JLG INDUSTRIES, INC.
MODELNUMBER: SERIAL NUMBER:
MAIN DECK CAPACITY: LBS.*
DO NOT EXCEED THE ABOVE STRUCTURAL RATINGS.
THE MAXIMUM EFFECTIVE TRANSPORT LOAD MAY BE LIMITED BY THE GAWR, GVWR OR GCWR
OF THE TRUCK CHASSIS. THE MAXIMUM EFFECTIVE TRANSPORT LOAD MAY BE LIMITED BY THE RATINGS OF ANY TOW IMPLEMENTS, ATTACHMENTS, OR ACCESSORIES BEING USED.
WHEN SUPPLIED, THE SAFETY LOCKING PIN
MUST BE IN PLACE DURING TRANSPORT TO ACHIEVE THE RATINGS LISTED ABOVE.
SAFETY IS NO ACCIDENT. REVIEW OPERATOR'S PRE-TRANSPORT CHECKLIST ON VEHICLE AND IN THE OWNERS MANUAL EACH TIME YOU MOVE A VEHICLE. FOLLOW ALL INSTRUCTIONS ON CONTROLS AND UNIT.
UPPER DECK CAPACITY: LBS.* WHEELLIFT/TOWBAR LIFT CAPACITY:
(FULL EXTENSION)
STRUCTURAL CAPACITIES*
LBS.* WHEELLIFT/TOWBAR TOW CAPACITY: LBS.*
HITCH OPTION TONGUE CAPACITY: (FULL RETRACTION) LBS.*
*PLEASE READ THE FOLLOWING IN ORDER TO ENSURE SAFE AND
CORRECT USE OF THE EQUIPMENT.
HITCH OPTION TONGUE CAPACITY: LBS.*
1001132765-A
13224 Fountainhead Plaza
Hagerstown, MD 21742
Phone (717) 597-7111
www.jerr-dan.com
FOR: MANUFACTURED BY: JLG INDUSTRIES, INC.
1001132764
1001132764
MODELNO: SERIAL NO:
DECK CAPACITY BS.*
WHEELLIFT LIFT CAPACITY LBS.*
WHEELLIFT TOW CAPACITY LBS.*
VIN.: C.A.: IN.
GROSS VEHICLE: LBS. (GVWR)
FRONT AXLE: LBS. (GVWR)
REAR AXLE: LBS. (GVWR)
LBS. ON CARRIER DECK
LBS. ON TOWBAR/WHEELLIFT
LOSS OF VEHICLE CONTROL, WHICHCOULD RESULT IN
SERIOUS BODILY INJURY OR DEATH, CAN OCCUR IF
EFFECTIVE TRANSPORT LOAD IS EXCEEDED.
DO NOTEXCEED THE FOLLOWINGWEIGHTS
LBS. ON CARRIER DECK WITH
LBS. ON TOWBAR/WHEELLIFT
THE MAXIMUM EFFECTIVE LOAD OF THIS UNIT IS BASED
ON GAWR AND GVWR SPECIFICATIONS OF THE TRUCK CHASSIS.
NOTE: THE DECK/WHEELLIFT CAPACITY INDICATES THE STRUCTURAL CAPACITY OF
THE COMPONENTS, NOT THE EFFECTIVE TRANSPORT LOAD.
MAXIMUM EFFECTIVE TRANSPORT LOAD IS AFFECTED BY THE CHASSIS ON
WHICH THE TOWING EQUIPMENT IS INSTALLED. BEFORE ATTEMPTING TO USE
THIS EQUIPMENT ON A CHASSIS OTHER THAN THAT SPECIFIED ABOVE,
CONTACT JERR-DAN TO OBTAIN A REVISED RATING.
SAFETY IS NO ACCIDENT. REVIEW OPERATOR'S PRE-TRANSPORT CHECKLIST
ON VEHICLE AND IN THE OWNERS MANUAL EACH TIME YOU MOVE A
VEHICLE. FOLLOW ALL INSTRUCTIONS ON CONTROLS AND UNIT.
13224 Fountainhead Plaza, Hagerstown, MD 21742
Phone (717) 597-7111, www.jerr-dan.com
FOR:
MANUFACTURED BY: JLG INDUSTRIES, INC.
1001132764-C
TRUCK CHASSIS INFORMATION
WINCH RATING EACH DRUM: LBS.
WIRE ROPE SIZE: FT
TYPE:
WORKING LOAD LIMIT:
LBS.
MODELNO: SERIAL NO:
DECK CAPACITY BS.*
WHEELLIFT LIFT CAPACITY LBS.*
WHEELLIFT TOW CAPACITY LBS.*
VIN.: C.A.: IN.
GROSS VEHICLE: LBS. (GVWR)
FRONT AXLE: LBS. (GVWR)
REAR AXLE: LBS. (GVWR)
LBS. ON CARRIER DECK
LBS. ON TOWBAR/WHEELLIFT
LOSS OF VEHICLE CONTROL, WHICHCOULD RESULT IN
SERIOUS BODILY INJURY OR DEATH, CAN OCCUR IF
EFFECTIVE TRANSPORT LOAD IS EXCEEDED.
DO NOTEXCEED THE FOLLOWINGWEIGHTS
LBS. ON CARRIER DECK WITH
LBS. ON TOWBAR/WHEELLIFT
THE MAXIMUM EFFECTIVE LOAD OF THIS UNIT IS BASED
ON GAWR AND GVWR SPECIFICATIONS OF THE TRUCK CHASSIS.
NOTE: THE DECK/WHEELLIFT CAPACITY INDICATES THE STRUCTURAL CAPACITY OF
THE COMPONENTS, NOT THE EFFECTIVE TRANSPORT LOAD.
MAXIMUM EFFECTIVE TRANSPORT LOAD IS AFFECTED BY THE CHASSIS ON
WHICH THE TOWING EQUIPMENT IS INSTALLED. BEFORE ATTEMPTING TO USE
THIS EQUIPMENT ON A CHASSIS OTHER THAN THAT SPECIFIED ABOVE,
CONTACT JERR-DAN TO OBTAIN A REVISED RATING.
SAFETY IS NO ACCIDENT. REVIEW OPERATOR'S PRE-TRANSPORT CHECKLIST
ON VEHICLE AND IN THE OWNERS MANUAL EACH TIME YOU MOVE A
VEHICLE. FOLLOW ALL INSTRUCTIONS ON CONTROLS AND UNIT.
13224 Fountainhead Plaza, Hagerstown, MD 21742
Phone (717) 597-7111, www.jerr-dan.com
FOR:
MANUFACTURED BY: JLG INDUSTRIES, INC.
1001132764-C
TRUCK CHASSIS INFORMATION
WINCH RATING EACH DRUM: LBS.
WIRE ROPE SIZE: FT
TYPE:
WORKING LOAD LIMIT:
LBS.
1001156252
1001156252
478
250 OR
SEMI-
ANNUALLY
1
3
7 HOLD DOWN GUIDE
WINCH GEAR BOX
HYD FILTER OIL
CHECK
CHANGE HYD FLUID
**
---- 2
1
1
1000
OPERATING
HOURS 3
6 WINCH GEAR BOX
HYD RESERVOIR DRAIN/FILL
DRAIN/FILL **
* 1
1
LUBRICATION CHART
CHART COVERS ONLY BODY COMPONENTS * INDICATES DUAL RANGE HYD. FLUID 5 W 20 AUTO TRANS FLUID MAY BE SUBSTITUTED IF NECESSARY
** CONSULT WINCH MANUAL FOR PROPER GRADE AND TYPE
50 OR
MONTHLY 2
4 CABLE
T - HANDLE OIL
OIL ENGINE OIL
ENGINE OIL 1
2
INTERVAL
(HOURS) REF
NO. IDENTIFICATION SERVICE LUBRICANT
DO NOT GREASE SLIDE PADS
NO. OF
POINTS
100 OR
BI-
MONTHLY
1
7 6
2 3
4 5
BIC ROLLBACK CARRIERS 2
6
5
WINCH FS CLEVIS
(IF APPLICABLE)
HYD RESERVOIR
CAM LOCK LUBE
CHECK
LUBE
MPG
*
MPG
1
1
2
SERIAL NO.
MODEL NO.
MANUF ACTURED BY :
JL G I NDUSTRIES, INC.
1001 127221-00
FOR:
478
250 OR
SEMI-
ANNUALLY
1
3
7 HOLD DOWN GUIDE
WINCH GEAR BOX
HYD FILTER OIL
CHECK
CHANGE
HYD FLUID
**
----
2
1
1
1000
OPERATING
HOURS
3
6 WINCH GEAR BOX
HYD RESERVOIR DRAIN/FILL
DRAIN/FILL **
*
1
1
LUBRICATION CHART
CHART COVERS ONLY BODY COMPONENTS
* INDICATES DUAL RANGE HYD. FLUID 5 W 20
AUTO TRANS FLUID MAY BE SUBSTITUTED IF NECESSARY
** CONSULT WINCH MANUAL FOR PROPER GRADE AND TYPE
50 OR
MONTHLY
2
4 CABLE
T - HANDLE OIL
OIL ENGINE OIL
ENGINE OIL 1
2
INTERVAL
(HOURS)
REF
NO.
IDENTIFICATION SERVICE LUBRICANT
DO NOT GREASE SLIDE PADS
NO. OF
POINTS
100 OR
BI-
MONTHLY
1
7 6
2 3
4 5
BIC ROLLBACK CARRIERS
2
6
5
WINCH FS CLEVIS
(IF APPLICABLE)
HYD RESERVOIR
CAM LOCK LUBE
CHECK
LUBE
MPG
*
MPG
1
1
2
SERIAL NO.
MODEL NO.
MANUF ACTURED BY :
JL G I NDUSTRIES, INC.
1001 127221-00
FOR:
1001153789
FRONT VIEW REAR VIEW
7330000478
1001127221
FIXED HEIGHT DECK MOUNTED HEADBOARD
7330000330
IN SIDE DECK
BEAM BY WINCH