Front Loading Utensil Washer Disinfector (WDF)
Operation, Maintenance and Installation Manual
Issue 1
Page
28
20/01/2022
10.0 Commissioning (To only be completed by qualified persons)
a)
Before switching on the device make sure the
DEVICE IS LEVEL
and the
WATER SUPPLY IS ON
. Check that the
DRAIN
HOSE
is connected.
b)
Turn on the power at the isolation switch and wait for device to power up. Once device has completed powering up it
will display “OFF”. Press the POWER button on the front panel to power on the device, the LCD display will illuminate
and display ready.
c)
Open the door and check that the chamber is clear and only contains the device baskets.
d)
Check that the sump tank screen is in place and has not dislodged.
e)
Check that the process chemical suction tubes have been installed into the detergent container and rinse aid container
if fitted. Device will perform a priming sequence on start, if chemicals are not correctly fitted a fault will be triggered.
f)
Once the above checks are completed it is recommended a cycle is run to ensure correct operation and to clean and
disinfect the device prior to use. Ensure the door is closed, a positive click will be heard when the door is shut
completely and “READY” will be displayed on the screen.
g)
Press “Start” to commence the set cycle, the door lock will engage and cycle will commence.
h)
The cycle will progress as per the sequence of operation steps in this manual, if the controller detects any faults during
the cycle these will be displayed on the screen.
Note:
It is recommended Installation Qualification test are performed as per the requirements of ISO 15883.1 prior to
use of the device.
11.0 Technical Data
11.1 Power and Water Consumption
POWER AND WATER CONSUMPTION DATA
MODEL
Disinfection
Setting
Avg Cycles per/Hr
Avg Cycle Time
min/sec
Avg kWh per
cycle
CW Avg Lt
Per cycle
WDF-3020
90°C x 1min
2
30
2.2
50
80°C x 10min
1.6
37.5
2.0
50
75°C x 30min
1.2
50
1.8
50
NOTE: Values may change due to operating and supply service conditions
Содержание WDF-3020
Страница 34: ......
Страница 35: ...Manufactured by Malmet Australia Pty Ltd ABN 95 001 717 791 www malmet com au Part No 92 2226...
